Auto Parts Search
2001 Chevrolet Venture CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2001 Chevrolet Venture car and truck
repair procedures including Chevrolet engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Chevrolet Venture automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2001 Chevrolet Venture AUTOMOBILES
Compressor Service -> Harrison V5 Variable Displacement Compressor -> Shaft Seal, Replace -> Installation -> Removal
Vehicle: 2001 Chevrolet Venture 3.4 V6 GAS
The shaft seal should not be replaced if only small amounts of oil are noted on adjacent surfaces. The shaft seal should only be replaced if a large amount of sprayed oil is observed, and then only after actual refrigerant leakage is found using an approved leak test procedure.
Removal
- Recover refrigerant as outlined under , then remove compressor drive belt.
- Reposition compressor, as needed, to gain access to clutch assembly and seal, or remove compressor and mount in suitable holding fixture.
- Remove clutch plate and hub assembly as outlined under "Compressor Clutch Service."
- Remo...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Chevrolet Venture AUTOMOBILES
Anti-lock Brakes -> Delphi Type VI -> System Service -> 1997-99 Montana, Silhouette, Trans Sport & Venture -> 2000-01 Montana, Silhouette & Venture -> ABS Lamp Driver Module -> Accelerometer -> Brake Modulator/Master Cylinder Assembly -> Brake Solenoid Valve -> Brake System Bleed -> Component Replacement -> Electronic Brake Control Module/Electronic Brake Traction Control Module (EBCM/EBTCM) -> Front Wheel Speed Sensor -> Front Wheel Speed Sensor Jumper Harness -> Manual Bleeding -> Montana, Silhouette, Trans Sport & Venture -> Pressure Bleeding -> Rear Wheel Speed Sensor -> Rear Wheel Speed Sensor Jumper Harness -> Tracker -> Traction Control System (TCS) Modulator/Motor Pack
Vehicle: 2001 Chevrolet Venture 3.4 V6 GAS
Brake System Bleed
Pressure Bleeding
Montana, Silhouette, Trans Sport & Venture
- Remove master cylinder cover, ensure reservoir is properly filled.
- Connect bleeder adapter tool No. J 35589, or equivalent, to master cylinder reservoir.
- Connect bleeder adapter to pressure bleeding equipment.
- Connect a clear plastic bleeder hose to modulator assembly rearward bleeder valve, submerge other end of hose into clean container partially filled with brake fluid.
- Adjust pressure bleeding equipment to 5-10 psi, then wait for approximately 30 seconds to ensure there is no leakage.
- Adjust pressure blee...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2001 Chevrolet Venture AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Filter Replacement -> Gasoline Engines Except Equinox, Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Uplander & Vue (2004-06) & 2004-06 Envoy, Rainier & TrailBlazer -> Returnless Fuel System
Vehicle: 2001 Chevrolet Venture 3.4 V6 GAS
Returnless Fuel System
On models equipped with fuel injected engines, relieve fuel system pressure as outlined under "Fuel System Pressure Relief."
On models equipped with metal collar quick disconnect connectors, GM tool No. J37088-A, or equivalent, will be required to disconnect the connector. Pri...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2001 Chevrolet Venture AUTOMOBILES
DRIVESHAFT, Replace -> Install -> Remove
Vehicle: 2001 Chevrolet Venture 3.4 V6 GAS
Remove
- Raise and support vehicle using a suitable lift.
- Reference mark propeller shaft at transfer case flange.
- Remove propeller shaft-to-transfer case flange bolts.
- Reference mark propeller shaft at torque tube flange.
- Remove propeller shaft-to-torque tube flange bolts.
- Push propeller shaft toward rear of vehicle.
- Remove propeller shaft.
Install
- Install rear of propeller shaft to torque tube flange.
- Align reference marks on propeller shaft and torque tube flange. Thoroughly clean and apply threadlocker GM P/N United States 12345493 P/N Canada 10953488 or equiva...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2001 Chevrolet Venture AUTOMOBILES
Alternator, Replace
Vehicle: 2001 Chevrolet Venture 3.4 V6 GAS
- Disconnect battery ground cable.
- Remove throttle body air inlet duct, then apply parking brake.
- Place transaxle in neutral gear position.
- Remove engine mount strut bolts and position mount aside.
- Install suitable engine tilt strap tool.
- R...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2001 Chevrolet Venture AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1998-2005 Montana, Silhouette, Trans Sport, Venture & 2002-03 Rendezvous
Vehicle: 2001 Chevrolet Venture 3.4 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Open the instrument panel compartment door.
- Remove the door located at the rear of the instrument panel compartment.
- Open the A/C and heater module access door, Fig. .
- Remove the first cabin air filter through the A/C and heater module access...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2001 Chevrolet Venture AUTOMOBILES
General Motors Corp./Saturn Trucks -> StabiliTrak Control System Warning Lamp ->
Vehicle: 2001 Chevrolet Venture 3.4 V6 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned On as a bulb check. If the warning...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2001 Chevrolet Venture AUTOMOBILES
Radiator, Replace
Vehicle: 2001 Chevrolet Venture 3.4 V6 GAS
- Remove air cleaner and duct assembly.
- Drain coolant into a suitable container.
- Loosen engine mount strut to engine mount strut bracket bolts.
- Loosen engine mount strut bracket brace bolts from upper radiator support bracket.
- Remove mounting bolts on radiator upper support and position engine mount strut and bracket to rear.
- Ensure ignition switch is in Off position, then disconnect cooling fan harness electrical co...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2001 Chevrolet Venture AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2001 Chevrolet Venture 3.4 V6 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2001 Chevrolet Venture AUTOMOBILES
Component location diagrams for most 2001 Chevrolet Venture cars and light trucks sold in the U.S. from 1990+.
 Passenger Compartment Diagram for 2001 Chevrolet Venture 3.4 V6 GASComponents on diagram: |
 Engine Compartment Diagram for 2001 Chevrolet Venture 3.4 V6 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2001 Chevrolet Venture AUTOMOBILES
OEM drawn wiring diagrams for most 2001 Chevrolet Venture cars and light trucks sold in the U.S.
 2001 Chevrolet Venture 3.4 V6 GAS Wiring DiagramComponents on diagram: |
 2001 Chevrolet Venture 3.4 V6 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2001 Chevrolet Venture AUTOMOBILES
OEM TSB listings for most 2001 Chevrolet Venture cars and light trucks sold in the U.S. from 1985+.
|
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2001 Chevrolet Venture 3.4 V6 GAS Auto Systems: |
|
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2001 Chevrolet Venture 3.4 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2001 Chevrolet Venture AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2001 Chevrolet Venture cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2001 Chevrolet Venture cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2001 Chevrolet Venture cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2001 Chevrolet Venture cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2001 Chevrolet Venture SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
