Auto Parts Search
2001 Ford ZX2 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Ford REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service

A/C & HEATER SERVICE PROCEDURES FOR 2001 Ford ZX2 AUTOMOBILES
General Service Domestic Vehicles -> 2001-02 -> Charging System -> Caravan, Town & Country & Voyager -> Cherokee, Dakota, Full Size Pickups, Liberty, PT Cruiser & Vans, Grand Cherokee & Wrangler -> Concorde, Intrepid, LHS & 300M -> DaimlerChrysler Corp. -> Ford Motor Company -> General Motors -> Neon -> Sebring & Stratus Coupe -> Sebring & Stratus Sedan & Sebring Convertible
Vehicle: 2001 Ford ZX2 2.0 L4 GAS
DaimlerChrysler Corp.
Sebring & Stratus Coupe
Never use cans to charge into high pressure side of system (compressor discharge port) or into system at high temperature, as high system pressure transferred into charging may cause it to explode.
- Attach center hose from manifold gauge set to refrigerant dispensing manifold. Turn refrigerant manifold valves completely counterclockwise to open fully, remove protective caps from refrigerant manifold.
- Screw refrigerant cans into manifold. Ensure gasket is in place and in good condition. Torq...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Ford ZX2 AUTOMOBILES
Disc Brakes -> Front Disc Brakes -> Rotor Replacement -> Installation -> Removal
Vehicle: 2001 Ford ZX2 2.0 L4 GAS
If caliper does not require servicing, do not disconnect brake hose or remove caliper from vehicle. Position caliper aside with wire or tie straps to avoid damaging caliper or hose.
If excessive force must be used to remove the rotor, then it should be inspected for lateral runout before installation.
Removal
- On models equipped with air suspension, turn service switch Off.
- On all models, raise and support vehicle, then remove wheel and tire assembly. Use care to avoid damage or interference with caliper bleeder screw fitting and brake rotor shield.
- Remove caliper anchor bracket bol...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2001 Ford ZX2 AUTOMOBILES
Ford Motor Co. Passenger Cars -> Fuel Filter Scheduled Maintenance -> 1998-03 Escort, ZX2, LN7, Lynx & Tracer -> Normal Service -> Severe Service
Vehicle: 2001 Ford ZX2 2.0 L4 GAS
Normal Service
Replac...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2001 Ford ZX2 AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2001 Ford ZX2 2.0 L4 GAS
- Raise and support vehicle.
- Remove lug nuts and remove front tire and wheel.
- Raise staked portion of front axle wheel hub retainer using a small cape chisel.
- Remove and discard front axle wheel hub retainer.
- Remove cotter pin and tie rod end nut.
- Use a suitable tool to separate tie rod end from front wheel knuckle.
- Remove stabilizer bar link.
- Remove nut and ball joint pinch bolt.
- Pry down on front suspension lower arm separating front suspension lower arm ball joint from front wheel knuckle.
- Pull outward on front wheel knuckle then pull front wheel driveshaft and joint from front w...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2001 Ford ZX2 AUTOMOBILES
Alternator, Replace
Vehicle: 2001 Ford ZX2 2.0 L4 GAS
- Disconnect battery ground cable.
- Remove alternator drive belt.
- Remove cover and disconnect electrical connectors.
- Remove alternator mounting bolt and secure coolant expansion tank aside.
- Secure power steering reservoir aside.
- Remove mounting bolt and secure engine wiring loom bracket aside.
- Disconnect ground ...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2001 Ford ZX2 AUTOMOBILES
Ford Motor Co. Cars -> Traction Control System Warning Lamp ->
Vehicle: 2001 Ford ZX2 2.0 L4 GAS
This lamp should light for a approximately 6-8 seconds when the ignition is turned On as a bulb check. If the warni...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2001 Ford ZX2 AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2001 Ford ZX2 2.0 L4 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Reposition heater core inlet hose clamp at engine.
- Remove hose from engine.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Drain cooling system into a suitable container.
- Reposition heater hose outlet clamp at heater core.
- Disconnect heater ou...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2001 Ford ZX2 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2001 Ford ZX2 2.0 L4 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2001 Ford ZX2 AUTOMOBILES
Component location diagrams for most 2001 Ford ZX2 cars and light trucks sold in the U.S. from 1990+.
![]() Components on diagram: |
![]() Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2001 Ford ZX2 AUTOMOBILES
OEM drawn wiring diagrams for most 2001 Ford ZX2 cars and light trucks sold in the U.S.
![]() Components on diagram: |
![]() Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2001 Ford ZX2 AUTOMOBILES
OEM TSB listings for most 2001 Ford ZX2 cars and light trucks sold in the U.S. from 1985+.
Document: RECALL - CERTAIN 1992-2003 MODEL YEAR CARS AND TRUCKS - FUSED JUMPER HARNESS REPLACEMENT FOR VEHICLES SERVICED WITH AN INCOMPATIBLE FUSED JUMPER HARNESS Vehicle: 2001 Ford ZX2 2.0 L4 GAS Auto Systems: |
Document: RECALL - 1992-2004 MULTIPLE VEHICLE LINES - SPEED CONTROL SYSTEM MODIFICATION Vehicle: 2001 Ford ZX2 2.0 L4 GAS |
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2001 Ford ZX2 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2001 Ford ZX2 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2001 Ford ZX2 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2001 Ford ZX2 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2001 Ford ZX2 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2001 Ford ZX2 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
![]() |
Access the Complete guide! |