Auto Parts Search
2001 Saturn LS Series CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Saturn REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2001 Saturn LS Series AUTOMOBILES
Air Bag System Precautions -> General Motors Corp. -> Arming -> Light Trucks & Vans -> Passenger Cars
Vehicle: 2001 Saturn LS Series 2.2 L4 GAS
Passenger Cars
Reverse disarming procedures to arm the Supplemental Restraint System, noting the following:
- Ensure all disconnected SRS electrical connectors are securely connected and routed.
- Install all removed fuses in proper locations.
- From a safe position at sides of or below air bag module, Turn ignition switch to ON position and observe Air Bag or SRS warning lamp.
- On all models except Prizm and 1990 Corvette, warning lamp should flash seven to nine times, then go off.
- On Prizm models, warning lamp should light for six seconds,...
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Saturn LS Series AUTOMOBILES
Disc Brakes -> Saturn -> Caliper Service -> Assemble -> Disassemble -> Front -> Ion -> L-Series -> Rear -> Replacement -> S-Series
Vehicle: 2001 Saturn LS Series 2.2 L4 GAS
S-Series
Front
Replacement
- Raise and support vehicle.
- Remove wheel assemblies.
- Disconnect caliper brake fluid lines and plug opening.
- Remove caliper lockpin, guide pin and pin boots.
- Remove caliper from caliper support, ensure not to damage pin boots.
- Remove brake pads.
- Remove two pad clips from caliper support.
- Reverse procedure to install.
Disassemble
- Inspect lockpin and guide pin boots for damage. replace as required.
- Inspect piston boot and lockpin for damage, replace as required.
- Remove piston boot ring and boot using a small screwdriver.
- Pad caliper interior with a suitable cushion, then...
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2001 Saturn LS Series AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Filter Scheduled Maintenance -> 1991-06 Saturn -> Normal Service -> Severe Service
Vehicle: 2001 Saturn LS Series 2.2 L4 GAS
Normal Service
Replace every 100,0...
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2001 Saturn LS Series AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2001 Saturn LS Series 3.0 V6 GAS
- With vehicle on ground, depress brake pedal and remove cotter and drive axle nut. Discard nut and cotter.
- Raise vehicle and support vehicle.
- Remove wheel and tire assembly corresponding to drive axle being removed.
- Remove tie rod end torque prevailing nut, discard nut. Do not attempt to separate joint using a wedge-type tool because seal may be damaged.
- Using a suitable puller, separate tie rod end from steering knuckle.
- Remove lower control arm to steering knuckle nut and bolt. Be careful not to allow steering knuckle to contact ball stud seal. Contact may cause seal to rip, ...
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2001 Saturn LS Series AUTOMOBILES
Alternator, Replace
Vehicle: 2001 Saturn LS Series 2.2 L4 GAS
- Disconnect battery ground cable.
- Remove throttle body air duct and accessory drive belt.
- Disconnect alternator elec...
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2001 Saturn LS Series AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 2000-05 Saturn L, LS & LW Series
Vehicle: 2001 Saturn LS Series 2.2 L4 GAS
Under normal operating conditions the cabin air filter should be replaced every 12 months or 12,000 miles. In dusty areas change the cabin air filter more often.
- Open the hood.
- Carefully open the cowl cabin air filter access door using a flat blade screwdriver, Fig. .
- Remove any leaves and debris form the filter housing area.
- Rotate the locking tabs outward to rel...
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2001 Saturn LS Series AUTOMOBILES
General Motors Corp./Saturn Cars -> Passlock Telltale Lamp -> 2000-09 Saturn
Vehicle: 2001 Saturn LS Series 3.0 V6 GAS
The instrument panel cluster contains the security telltale lamp. The security telltale has three modes of operation: Off, Flashing and On. The security telltale will be off if ignition is in the off position or if the ignition is in the Run, Start or Acc position and the security system diagnostics have all passed. The security telltale will be on if the body control module (BCM) is performing a bulb test at vehicle start up, the security system diagnostics have not yet completed at vehicle start up or if a security s...
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2001 Saturn LS Series AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2001 Saturn LS Series 2.2 L4 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition inlet heater hose clamp from heater core pipe.
- Remove hose from heater core.
- Reposition heater hose clamp from engine.
- Remove inlet heater hose from engine.
- Remove hose from vehicle.
- Reverse procedure to...
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2001 Saturn LS Series AUTOMOBILES
Serpentine Drive Belt, Replace -> Installation -> Removal
Vehicle: 2001 Saturn LS Series 2.2 L4 GAS
Removal
- Mark belt running direction.
- Depress tensioner arm using suitable 3/8 inch drive breaker bar.
- Remove belt from idler or air conditioning compressor pulley and accessor...
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2001 Saturn LS Series AUTOMOBILES
Component location diagrams for most 2001 Saturn LS Series cars and light trucks sold in the U.S. from 1990+.
Anti-Lock Brake System Components Diagram for 2001 Saturn LS Series 2.2 L4 GAS Components on diagram: |
HVAC Module Components Diagram for 2001 Saturn LS Series 3.0 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2001 Saturn LS Series AUTOMOBILES
OEM drawn wiring diagrams for most 2001 Saturn LS Series cars and light trucks sold in the U.S.
2001 Saturn LS Series 2.2 L4 GAS Wiring Diagram Components on diagram: |
2001 Saturn LS Series 3.0 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2001 Saturn LS Series AUTOMOBILES
OEM TSB listings for most 2001 Saturn LS Series cars and light trucks sold in the U.S. from 1985+.
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2001 Saturn LS Series 3.0 V6 GAS Auto Systems: |
Document: EVAP Emissions Small Leak Diagnosis (DTC P0442) Vehicle: 2001 Saturn LS Series 3.0 V6 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2001 Saturn LS Series AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2001 Saturn LS Series cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2001 Saturn LS Series cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2001 Saturn LS Series cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2001 Saturn LS Series cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2001 Saturn LS Series SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2001 Saturn LS Series vehicle. |
Access the Complete guide! |