Auto Parts Search
We have info for following modifications of 2001 Volvo V70
- 2001 Volvo V70 2.4 L5 GAS, CC:2435, Fuel Injection
- 2001 Volvo V70 2.4 L5 GAS, CC:2435, Fuel Injection
- 2001 Volvo V70 2.3 L5 GAS, CC:2319, Fuel Injection
BRAKE SERVICE PROCEDURES FOR 2001 Volvo V70 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2001 Volvo V70 cars and light trucks from 1990+.
Hydraulic Brake Systems -> Brake System Bleed -> Less Bleeding Unit -> With Bleeding Unit
Vehicle: 2001 Volvo V70 2.3 L5 GAS
With Bleeding Unit
- Ensure ignition switch is turned Off.
- Raise and support vehicle.
- Clean filer cap on brake fluid reservoir and surrounding area.
- Remove filler cap.
- Set bleeding unit to 29-43 psi.
- Connect bleeding unit to brake fluid reservoir.
- Depress brake pedal several times to expel any air bubbles from master cylinder. Repeat this step between bleeding each brake caliper.
- Start at front lefthand wheel, remove protective cap from bleed nipple and connect hose from drain bottle.
- Open bleed nipple and close it again once no further air bubbles can be seen in fluid.
- Tighten bleed nip...
CLICK HERE TO GET FULL ACCESS TO 2001 Volvo V70 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Volvo V70 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2001 Volvo V70 cars and light trucks from 1990+.
Disc Brakes -> Caliper Service -> Rear -> Removal & Overhaul
Vehicle: 2001 Volvo V70 2.4 L5 GAS
Rear
Removal & Overhaul
- Raise and support rear of vehicle, then remove rear tires.
- Disconnect brake lines, then remove two caliper attaching bolts and caliper.
- Remove piston dust cover, then place a piece of wood or suitable material between both pistons. Force pistons out of bore using low pressure compressed air.
- Remove sealing rings, then bleeder screw. Do not separate brake caliper into two separate halves.
- Clean caliper assembly thoroughly using brake fluid or denatured alcohol.
- Remove any ...
CLICK HERE TO GET FULL ACCESS TO 2001 Volvo V70 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Volvo V70 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2001 Volvo V70 cars and light trucks from 1990+.
Hydraulic Brake Systems -> Component Replacement -> Master Cylinder -> Pressure Differential Warning Valve -> Regulating Valve
Vehicle: 2001 Volvo V70 2.3 L5 GAS
Master Cylinder
- Place a cover over the fender to protect paint from brake fluid.
- Disconnect brake lines and cap openings.
- Remove retaining nuts, then the master cylinder.
- Reverse procedure to install. Bleed master cylinder prior to installation.
Regulating Valve
The regulating valve must be replaced as an assembly.
- Disconnect brake pipe from valve, replace unions if required.
- ...
CLICK HERE TO GET FULL ACCESS TO 2001 Volvo V70 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Volvo V70 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2001 Volvo V70 cars and light trucks from 1990+.
Anti-lock Brakes -> System Service -> Brake System Bleed -> Component Replacement -> Control Module -> Hydraulic Modulator -> Less Multi-Link Rear Suspension -> Multi-Link Suspension -> Rear Sensor
Vehicle: 2001 Volvo V70 2.4 L5 GAS
Brake System Bleed
Refer to "Brake System Bleed" section under "Hydraulic Brake Systems."
Component Replacement
Control Module
- Ensure ignition is off.
- Remove sound proofing under instrument panel.
- Loosen band holding control module and lift module out.
- Remove control module connector.
- Reverse procedure to install.
Hydraulic Modulator
- Remove cover over hydraulic modulator.
- Remove both relays and connector.
- Disconnect ground lead from modulator
- Remove hydraulic lines to modulator noting position for installation.
- Remove screw from support and push support to right. Remove hydraulic modulator
- Reverse ...
CLICK HERE TO GET FULL ACCESS TO 2001 Volvo V70 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Volvo V70 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2001 Volvo V70 cars and light trucks from 1990+.
Disc Brakes -> Rotor, Replace -> Front -> Rear
Vehicle: 2001 Volvo V70 2.4 L5 GAS
Front
- Remove retaining spring from caliper.
- Remove mounting bolts, then the caliper. Hang caliper from a steel wire as not to damage brake hose.
- Remove caliper mounting bracket.
- Remove rotor locating pins, then the rotor.
- Reverse procedure to install. Tighten locating pin and caliper mounting bracket bolts to specifications.
Rear
- Press out split pins with a .12 (3mm) mandrel, the remove retaining spring...
CLICK HERE TO GET FULL ACCESS TO 2001 Volvo V70 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Volvo V70 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2001 Volvo V70 cars and light trucks from 1990+.
Disc Brakes -> Tightening Specifications
Vehicle: 2001 Volvo V70 2.4 L5 GAS
CLICK HERE TO GET FULL ACCESS TO 2001 Volvo V70 BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2001 Volvo V70 vehicle. |
Access the Complete guide! |