Auto Parts Search
2003 Chevrolet Silverado CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2003 Chevrolet Silverado car and truck
repair procedures including Chevrolet engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Chevrolet Silverado automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2003 Chevrolet Silverado AUTOMOBILES
Compressor Service -> Denso Compressor -> Clutch & Coil, Replace
Vehicle: 2003 Chevrolet Silverado SS 6.0 V8 GAS
- Raise and suitably support vehicle.
- Remove engine protection shield.
- Relieve tension by rotating tensioner clockwise and remove drive belt, Fig. .
- Remove mo...
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2003 Chevrolet Silverado AUTOMOBILES
Power Brake Units -> Delco Brake Booster -> Power Brake Unit Replacement -> Aztek & Rendezvous -> C & K Series -> Express & Savana -> Montana, Silhouette, Trans Sport & Venture -> S & T Series -> Vue
Vehicle: 2003 Chevrolet Silverado SS 6.0 V8 GAS
Aztek & Rendezvous
- Remove coolant reservoir, then relieve fuel system pressure as outlined under. "Precautions."
- Remove cruise control cable from module, then disconnect electrical connector from cruise control module.
- Remove cruise control module from bracket, then the front end sheet metal diagonal brace.
- Remove PCM cover from air cleaner housing, then the PCM and set aside.
- Remove air cleaner intake duct, then bolts from air cleaner assembly and housing.
- Remove fuel lines from pipes and vapor line, then disconnect fluid level sensor switch from brake master cylinder.
- Disc...
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2003 Chevrolet Silverado AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Fuel Filter Replacement -> Gasoline Engines Except Equinox, Montana SV6, Relay, Rendezvous w/3.6L Engine, Terraza, Uplander & Vue (2004-06) & 2004-06 Envoy, Rainier & TrailBlazer -> Returnless Fuel System
Vehicle: 2003 Chevrolet Silverado SS 6.0 V8 GAS
Returnless Fuel System
On models equipped with fuel injected engines, relieve fuel system pressure as outlined under "Fuel System Pressure Relief."
On models equipped with metal collar quick disconnect connectors, GM tool No. J37088-A, or equivalent, will be required to disconnect the connector. Pri...
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2003 Chevrolet Silverado AUTOMOBILES
DRIVESHAFT, Replace -> Front -> Rear
Vehicle: 2003 Chevrolet Silverado SS 6.0 V8 GAS
Front
Before disassembly, observe and accurately reference mark all driveline components relative to the propeller shaft and axles. These items include the propeller shafts, wheel drive shafts, pinion flanges and output shafts
Assemble all components in the exact relationship to each other as they were prior to removal. Observe all published specifications and torque values, and any measurements obtained prior to disassembly.
- Raise and support vehicle.
- Remove transfer case shield, if equipped.
- If equipped with double clamp style boot, remove clamp at transfer case by prying up ex...
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2003 Chevrolet Silverado AUTOMOBILES
Starter, Replace
Vehicle: 2003 Chevrolet Silverado SS 6.0 V8 GAS
- Disconnect battery ground cable.
- Remove mounting bolts and engine shield, if required.
- Remove mounting bolts and oil pan skid plate, if required.
- Remove righthand transmission cover bolt.
- Remove front axle mounting bracket nut, then position front axle mounting bracket bolt until tip is flush with support bushing. Do not remove bolt.
- Remove mounting bolts and slide starter forward until it clears transmission.
- Disconnect oil level sensor electrical connector.
- Remove start...
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2003 Chevrolet Silverado AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2003 Chevrolet Silverado SS 6.0 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2003 Chevrolet Silverado AUTOMOBILES
General Motors Corp./Saturn Trucks -> Service Four Wheel Drive (4WD) System Warning Lamp ->
Vehicle: 2003 Chevrolet Silverado SS 6.0 V8 GAS
This lamp should light for approximately 6-8 seconds when the ignition is turned On as a bulb check. If the ...
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2003 Chevrolet Silverado AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2003 Chevrolet Silverado SS 6.0 V8 GAS
Inlet
- Drain cooling system into a suitable container.
- Remove air intake tube.
- Remove heater and surge tank hose from mounting clip.
- Reposition heater core inlet hose clamp at engine coolant inlet fitting.
- Remove hose from engine coolant inlet fitting.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from ...
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2003 Chevrolet Silverado AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2003 Chevrolet Silverado SS 6.0 V8 GAS
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2003 Chevrolet Silverado AUTOMOBILES
Component location diagrams for most 2003 Chevrolet Silverado cars and light trucks sold in the U.S. from 1990+.
 I/P Harness Routing Diagram for 2003 Chevrolet Silverado SS 6.0 V8 GASComponents on diagram: |
 Right Side of the I/P Diagram for 2003 Chevrolet Silverado SS 6.0 V8 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2003 Chevrolet Silverado AUTOMOBILES
OEM drawn wiring diagrams for most 2003 Chevrolet Silverado cars and light trucks sold in the U.S.
 2003 Chevrolet Silverado SS 6.0 V8 GAS Wiring DiagramComponents on diagram: |
 2003 Chevrolet Silverado SS 6.0 V8 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2003 Chevrolet Silverado AUTOMOBILES
OEM TSB listings for most 2003 Chevrolet Silverado cars and light trucks sold in the U.S. from 1985+.
|
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2003 Chevrolet Silverado SS 6.0 V8 GAS Auto Systems: |
|
Document: Power Folding Mirrors Will Not Fold Inward Vehicle: 2003 Chevrolet Silverado SS 6.0 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2003 Chevrolet Silverado AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2003 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2003 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2003 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2003 Chevrolet Silverado cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2003 Chevrolet Silverado SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
