Auto Parts Search
2004 Chrysler PT Cruiser CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chrysler REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2004 Chrysler PT Cruiser car and truck
repair procedures including Chrysler engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Chrysler PT Cruiser automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2004 Chrysler PT Cruiser AUTOMOBILES
Air Bag System Precautions -> DaimlerChrysler -> Arming -> 1990-97 -> 1994-96 Cherokee -> 1998-2004 -> Except 1994-96 Cherokee -> Light Truck & Vans -> Passenger Cars
Vehicle: 2004 Chrysler PT Cruiser Turbo 2.4 L4 GAS
Passenger Cars
1990-97
- Ensure no one is inside vehicle and ignition switch is in Lock position.
- Connect battery ground cable.
- Turn ignition switch to On position from passenger side of vehicle.
- The SRS warning lamp should light for six to eight seconds, then remain off for at least 45 seconds to indicate if SRS is functioning properly.
1998-2004
- Ensure no one is inside vehicle and ignition switch is in Lock position.
- Connect battery ground or remote cable or terminal.
- Turn ignition On from a safe position be...
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2004 Chrysler PT Cruiser AUTOMOBILES
Power Brake Units -> Power Brake Unit Service -> Caravan, Town & Country & Voyager -> Commander -> Dakota & Durango -> Full Size Pickup -> Grand Cherokee -> Hydraulic Booster -> Installation -> Liberty -> Pacifica -> PT Cruiser -> Removal -> Replacement -> Sprinter -> Vacuum Booster -> Wrangler
Vehicle: 2004 Chrysler PT Cruiser 2.4 L4 GAS
The only serviceable power brake booster components are the vacuum hose and the check valve. The power brake booster must be serviced as an assembly. If diagnosis indicates a power brake booster fault condition, the unit must be replaced as an assembly.
Replacement
Caravan, Town & Country & Voyager
- With engine stopped, pump brake pedal four or five times to deplete power booster vacuum.
- Disconnect both battery cables, then remove battery thermo guard and battery from tray.
- Remove air inlet resonator and hoses as an assembly from throttle body and air cleaner housing.
- Remove c...
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2004 Chrysler PT Cruiser AUTOMOBILES
DaimlerChrysler Corp./Jeep Light Trucks, SUVs & Vans -> Fuel Filter Replacement -> PT Cruiser
Vehicle: 2004 Chrysler PT Cruiser 2.4 L4 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of ...
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2004 Chrysler PT Cruiser AUTOMOBILES
CV AXLE SHAFT, Replace -> Install -> Remove
Vehicle: 2004 Chrysler PT Cruiser 2.4 L4 GAS
Remove
- Disconnect negative battery cable.
- Place transaxle in gated park.
- Raise vehicle on hoist.
- Remove wheel and tire assembly.
- Remove cotter pin, nut lock, spring washer and hub nut from end of outer C/V joint stub axle.
- On models equipped with ABS, disconnect front wheel speed sensor and secure harness out of the way.
- Remove nut and bolt retaining ball joint stud into steering knuckle.
- Separate ball joint stud from steering knuckle by prying down on lower control arm. Use caution when separating ball joint stud from steering knuckle, so ball joint seal does not get damaged.
- Rem...
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2004 Chrysler PT Cruiser AUTOMOBILES
Alternator, Replace
Vehicle: 2004 Chrysler PT Cruiser 2.4 L4 GAS
- Remove air cleaner lid, disconnect inlet air sensor and makeup air hose.
- Remove battery ground cable.
- Loosen upper alternator T-bolt lock nut.
- Raise and support vehicle.
- Remove right front wheel.
- Remove accessory drive splash shield.
- Remove pencil strut.
- Loosen lower pivot bolt.
- Loosen accessory drive belt T-bolt.
- Unplug field circuit from alternator.
- Remove B+ terminal nut and wire.
- Remove alternator belt.
- Remove axle retaining nut.
- Remove lower control arm from steering knuckle.
- Remove axle shaft. Put a container under tr...
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2004 Chrysler PT Cruiser AUTOMOBILES
Cabin Air Filter Service -> Chrysler LLC -> 2002-09 PT Cruiser
Vehicle: 2004 Chrysler PT Cruiser Turbo 2.4 L4 GAS
The cabin air filter should be replaced every 15,000 miles.
- Open the hood.
- Remove the passenger side cowl grille screen.
- Remove the three windshield washer reservoir to body attaching screws, then position the reservoir out of the way.
- Lift the cabin air filter eleme...
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2004 Chrysler PT Cruiser AUTOMOBILES
Chrysler LLC Trucks -> Check Engine Lamp -> Chrysler, Dodge, Jeep & Plymouth Except Ram 50
Vehicle: 2004 Chrysler PT Cruiser 2.4 L4 GAS
On models less OBD II, the Check Engine lamp should light for approximately 3 seconds after the ignition has been turned On as a bulb inspection. If improper or no signals are received by the Powertrain Control Module (PCM) from various sensors and monitored systems or if the PCM enters its Limp-In mode, the PCM will light the Check Engine lamp. On Chrysler, Dodge and Plymouth models, After diagnosing and servicing the vehicle, the PCM memory will be cleared after approximately 40 to 100 ignition key On-Off cycles or by using a suitable scan tool. ...
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2004 Chrysler PT Cruiser AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2004 Chrysler PT Cruiser 2.4 L4 GAS
Lower
- Raise and support vehicle.
- Drain cooling system into a suitable container.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator.
- Reposition hose clamp from water inlet tube.
- Remove radiator outlet hose from water inlet tube and from vehicl...
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2004 Chrysler PT Cruiser AUTOMOBILES
Serpentine Drive Belt, Replace -> Alternator Belt -> Power Steering Belt & A/C Compressor Belt
Vehicle: 2004 Chrysler PT Cruiser 2.4 L4 GAS
Power Steering Belt & A/C Compressor Belt
- Remove right front splash shield.
- Release tension by rotating tensioner clockwise until belt can be removed from power steering pump pulley.
- Remove drive belt.
- Reverse procedure to ...
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2004 Chrysler PT Cruiser AUTOMOBILES
Component location diagrams for most 2004 Chrysler PT Cruiser cars and light trucks sold in the U.S. from 1990+.
 Engine Compartment Components Diagram for 2004 Chrysler PT Cruiser 2.4 L4 GASComponents on diagram: |
 Relays Diagram for 2004 Chrysler PT Cruiser 2.4 L4 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2004 Chrysler PT Cruiser AUTOMOBILES
OEM drawn wiring diagrams for most 2004 Chrysler PT Cruiser cars and light trucks sold in the U.S.
 2004 Chrysler PT Cruiser 2.4 L4 GAS Wiring DiagramComponents on diagram: |
 2004 Chrysler PT Cruiser 2.4 L4 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2004 Chrysler PT Cruiser AUTOMOBILES
OEM TSB listings for most 2004 Chrysler PT Cruiser cars and light trucks sold in the U.S. from 1985+.
|
Document: Hard To Fill Or Fuel Nozzle Shuts Off Repeatedly Vehicle: 2004 Chrysler PT Cruiser 2.4 L4 GAS Auto Systems: |
|
Document: Chrome Clad Wheel Adapters For Proper Balancing Vehicle: 2004 Chrysler PT Cruiser 2.4 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2004 Chrysler PT Cruiser AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2004 Chrysler PT Cruiser cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2004 Chrysler PT Cruiser cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2004 Chrysler PT Cruiser cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2004 Chrysler PT Cruiser cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2004 Chrysler PT Cruiser SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
