Auto Parts Search
2005 GMC Yukon CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT GMC REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2005 GMC Yukon car and truck
repair procedures including GMC engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your GMC Yukon automobile. Try the Automotix DIY solution today!
BRAKE SERVICE PROCEDURES FOR 2005 GMC Yukon AUTOMOBILES
Hydraulic Brake Systems -> Description -> Hydraulic Control Valves -> Master Cylinder
Vehicle: 2005 GMC Yukon SLT 5.3 V8 GAS
Master Cylinder
Some vehicles use a conventional tandem master cylinder with two hydraulic pistons operating in-line. The primary piston controls the front brake system and the secondary piston controls the rear brake system.
Other models use a master cylinder that operates the same as the conventional master cylinder, but also incorporates a quick take-up feature in the rear chamber to reduce excessive pedal travel which may result from increased fluid displacement required to move the low drag caliper piston out against the rotor.
The quick take-up uses a spring-loaded ball check val...
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 GMC Yukon AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Component Locations -> 1999-06 Escalade, Avalanche & Denali, 1988-03 & C/K Pickup (Except 1999-03 Sierra & Silverado), 1992-06 Blazer, Jimmy, Hummer H2, SSR, Suburban, Yukon XL, Tahoe, Yukon, Bravada Gasoline Engines & 2004-06 Rainier, TrailBlazer & Envoy
Vehicle: 2005 GMC Yukon SLE 4.8 V8 GAS
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 GMC Yukon AUTOMOBILES
DRIVESHAFT, Replace -> Front -> Rear
Vehicle: 2005 GMC Yukon SLT 4.8 V8 GAS
Front
Before disassembly, observe and accurately reference mark all driveline components relative to the propeller shaft and axles. These items include the propeller shafts, wheel drive shafts, pinion flanges and output shafts
Assemble all components in the exact relationship to each other as they were prior to removal. Observe all published specifications and torque values, and any measurements obtained prior to disassembly.
- Raise and support vehicle.
- Remove transfer case shield, if equipped.
- If equipped with double clamp style boot, remove clamp at transfer case by prying up ex...
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2005 GMC Yukon AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Aids -> Diagnostic Check -> Diagnostic Tests -> Intermittent & Poor Connections -> Intermittents -> Poor Connections -> Test Procedures
Vehicle: 2005 GMC Yukon SLT 4.8 V8 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Tests
Test Procedures
Refer to Figs. through for diagnostic test procedures.
Diagnostic Check
- Check for aftermarket devices which could affect the operation of the TPMS to verify that none are installed.
- Check the easily accessible or visible system components for obvious damage or conditions which could cause the symptom.
- Ensure that the scan tool selected front and rear tire pressure parameters are correct compared to the tire...
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 GMC Yukon AUTOMOBILES
Starter, Replace
Vehicle: 2005 GMC Yukon SLT 4.8 V8 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Disconnect starter battery positive cable and wiring harness.
- Remove starter motor mounting bolts, washers, shims, starter and heat shield from vehicle.
- Rever...
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2005 GMC Yukon AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1999-2007 Silverado, Sierra, 2000-07 Denali, Suburban, Tahoe, Yukon, Yukon XL, 2001-07 Escalade & 2002-07 Avalanche
Vehicle: 2005 GMC Yukon SLE 5.3 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Remove the righthand instrument panel hush panel.
- Remove the A/C and heater modul...
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 GMC Yukon AUTOMOBILES
General Motors Corp./Saturn Trucks -> Service Throttle Soon Indicator Lamp ->
Vehicle: 2005 GMC Yukon SLE 5.3 V8 GAS
A "Service Throttle Soon" indicator lamp is mounted in the lower righthand instrument cluster corner on these models. It lights when the ignition is turned On, but should go out approximately 1-5 seconds after the engine starts.
Traditional throttle cables are no longer used on these models. The PCM receives signals from an electron...
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 GMC Yukon AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2005 GMC Yukon SLE 4.8 V8 GAS
Lower
- Drain cooling system into a suitable container.
- Remove air cleaner outlet duct clamps at throttle body and mass air flow (MAF)/intake air temperature (IAT) sensor.
- Remove radiator inlet hose clip from outlet hose.
- Remove air cleaner outlet duct.
- Reposition hose clamp from water pump housing.
- Remove radiator outlet hose from water pump housing.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator and from vehicle.
- Reverse procedure to install.
Upper
- Drain cooling system into a suitable ...
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 GMC Yukon AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 GMC Yukon SLE 5.3 V8 GAS
- Rotate tensioner clockwise to release belt tension using suitable wrench, then remove belt.
- Route belt over pulleys excep...
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 GMC Yukon AUTOMOBILES
Component location diagrams for most 2005 GMC Yukon cars and light trucks sold in the U.S. from 1990+.
 LF Corner of the Bumper Diagram for 2005 GMC Yukon SLT 5.3 V8 GASComponents on diagram: |
 Roof Harness Diagram for 2005 GMC Yukon SLT 5.3 V8 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 GMC Yukon AUTOMOBILES
OEM drawn wiring diagrams for most 2005 GMC Yukon cars and light trucks sold in the U.S.
 2005 GMC Yukon SLE 5.3 V8 FLEX Wiring DiagramComponents on diagram: |
 2005 GMC Yukon SLE 5.3 V8 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 GMC Yukon AUTOMOBILES
OEM TSB listings for most 2005 GMC Yukon cars and light trucks sold in the U.S. from 1985+.
|
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2005 GMC Yukon SLE 4.8 V8 GAS Auto Systems: |
|
Document: GM of Canada New Vehicle Limited Warranty Tire Program Vehicle: 2005 GMC Yukon SLE 4.8 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 GMC Yukon AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 GMC Yukon cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 GMC Yukon cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 GMC Yukon cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 GMC Yukon cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 GMC Yukon SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
