Auto Parts Search
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2007 Chevrolet Express 1500 car and truck
repair procedures including Chevrolet engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your 2007 Chevrolet Express 1500 automobile. Try the Automotix DIY solution today!
We have info for following modifications of 2007 Chevrolet Express 1500
- 2007 Chevrolet Express 1500 4.3 V6 GAS, CID:262, Fuel Injection, Aspiration:262, Engine VIN:, Desg:X
- 2007 Chevrolet Express 1500 LT 5.3 V8 GAS, CID:325, Fuel Injection, Aspiration:325, Engine VIN:, Desg:T
- 2007 Chevrolet Express 1500 LT 5.3 V8 FLEX, CC:5328, CID:325, Fuel Injection, Aspiration:325, Engine VIN:, Desg:Z
- 2007 Chevrolet Express 1500 LS 5.3 V8 GAS, CID:325, Fuel Injection, Aspiration:325, Engine VIN:, Desg:T
- 2007 Chevrolet Express 1500 LS 5.3 V8 FLEX, CC:5328, CID:325, Fuel Injection, Aspiration:325, Engine VIN:, Desg:Z
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Express 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Express 1500 cars and light trucks from 1990+.
Disc Brakes -> Delco Dual Piston Sliding Caliper -> Caliper Service -> Assemble -> Disassemble -> Inspection -> Installation -> Removal
Vehicle: 2007 Chevrolet Express 1500 LS 5.3 V8 FLEX
Removal
- Siphon 2/3 of the brake fluid from master cylinder.
- Raise and support vehicle.
- Remove tire and wheel assembly.
- Compress caliper pistons until they bottom in bores using suitable clamp, Fig. .
- Disconnect brake hose at caliper by removing inlet fitting bolt.
- Remove mounting bolts and caliper.
Inspection
Should it become required to remove the caliper for installation of new components, clean components in denatured alcohol, wipe dry using lint-free cloths. Blow out drilled passages and holes using compressed air. Inspect dust boots for punctures or tears. If punctures or tears are...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Express 1500 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Express 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Express 1500 cars and light trucks from 1990+.
Power Brake Units -> Delco Brake Booster -> Description -> Operation -> Single Diaphragm Type -> Tandem (Dual) Diaphragm Type
Vehicle: 2007 Chevrolet Express 1500 LT 5.3 V8 FLEX
In order to properly service power brake systems, a thorough understanding of the various power assist systems is required. These systems provide a mechanical assist, acting to increase the force applied to the master cylinder piston by the driver while decreasing the effort required to obtain acceptable stopping performance. Two basic types of power assist mechanisms are used: vacuum assist diaphragm assemblies which use engine vacuum and in some cases vacuum from an external vacuum pump, and hydraulic assist assemblies which use hydraulic pressure developed by an external pump (us...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Express 1500 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Express 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Express 1500 cars and light trucks from 1990+.
Disc Brakes -> Delco Single Piston Sliding Caliper -> Troubleshooting -> Brake Rattle -> Brake Roughness Or Chatter; Pedal Pumping -> Caliper Brake Fluid Leak -> Excessive Pedal Effort -> Excessive Pedal Travel -> Heavy Brake Drag -> No Braking Effect When Brake Pedal Is Depressed -> Pull, Uneven Or Grabbing Brakes -> Rear Brakes Locking On Application
Vehicle: 2007 Chevrolet Express 1500 LS 5.3 V8 GAS
Excessive Pedal Travel
- Worn brake linings.
- Disc pads knock back after cornering or rough road travel.
- Piston and linings not properly seated or positioned.
- Insufficient fluid in system.
- Loose wheel bearing adjustment.
- Damaged or worn caliper piston seal.
- Improper booster pushrod adjustment.
- Pads out of flat more than .005 inch.
- Rear brake automatic adjusters inoperative.
- Improperly ground rear brake shoes.
Brake Roughness Or Chatter; Pedal Pumping
- Excessive lateral runout of rotor.
- Rotor excessively out of parallel.
Excessive Pedal Effort
- Frozen or seized pistons.
- Brake fluid, oil or grease on ...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Express 1500 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Express 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Express 1500 cars and light trucks from 1990+.
Hydraulic Brake Systems -> Adjustments -> Height Sensing Proportioning Valve
Vehicle: 2007 Chevrolet Express 1500 LT 5.3 V8 GAS
Height Sensing Proportioning Valve
The height sensing proportioning valve must be adjusted whenever the valve and/or linkage is disassembled or removed for service. In addition, adjustment should be inspected if excessive front wheel lock-up is experienced with a lower than desired brake application rate when vehicle is at or near maximum GVWR.
- Raise and support vehicle, leave wheels on and allow axle to hang freely.
- Remove lever retaining nut and disconnect lever from valve shaft, Fig. .
- Rotate valve shaft to permit installation of correct adjustment gauge, Fig. , ensure D shaped hol...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Express 1500 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Express 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Express 1500 cars and light trucks from 1990+.
Disc Brakes -> Delco Single Piston Sliding Caliper -> Rotor, Replace -> 2WD Models -> 4WD Models -> Front -> Rear
Vehicle: 2007 Chevrolet Express 1500 4.3 V6 GAS
2WD Models
Front
- Raise and support vehicle.
- Remove tire and wheel assembly.
- Remove caliper as outlined in .
- Remove grease cap from hub/rotor, Fig. .
- Remove cotter pin, nut and washer.
- Remove hub/rotor from spindle, being careful not to damage spindle threads or outer bearing.
- Reverse procedure to install, noting the following:
- Apply high-temperature wheel bearing grease to inner and outer wheel bearings.
- Torque nut to 12 ft. lbs., while turning wheel assembly forward by hand, back nut off one flat or until hole i...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Express 1500 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 Chevrolet Express 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 Chevrolet Express 1500 cars and light trucks from 1990+.
Power Brake Units -> Delco Brake Booster -> Power Brake Unit Service
Vehicle: 2007 Chevrolet Express 1500 LS 5.3 V8 GAS
The power brake unit is n...
CLICK HERE TO GET FULL ACCESS TO 2007 Chevrolet Express 1500 BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 2007 Chevrolet Express 1500 vehicle.
|
| Access the Complete guide! |
