Auto Parts Search
2007 Dodge Magnum CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Dodge REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Dodge Magnum AUTOMOBILES
Power Brake Units -> Power Brake Unit Service -> Caliber & 2007 Sebring Sedan -> Charger, Magnum & 300 -> Concorde, Intrepid & 300M -> Crossfire -> Less ABS -> Master Cylinder, Replace -> Neon -> Power Booster, Replace -> Sebring Convertible, Stratus Sedan & 2004-06 Sebring Sedan -> Sebring Coupe & Stratus Coupe -> With ABS -> Without ABS
Vehicle: 2007 Dodge Magnum SRT8 6.1 V8 GAS
Power Booster, Replace
Caliber & 2007 Sebring Sedan
- Remove PCM mounting fasteners, then position PCM aside.
- Remove master cylinder as outlined under "Master Cylinder, Replace."
- Disconnect rear brake tubes at junction block. Plug all open brake tubes.
- Disconnect vacuum hose from check valve on power brake booster.
- Remove lower instrument panel/steering column cover.
- Remove and discard brake lamp switch.
- Remove brake booster push rod to brake pedal retaining clip. Discard clip.
- Slide booster push rod off brake pedal pin.
- Remove brake booster to dash panel retaining nuts.
- Remove brake ...
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Dodge Magnum AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2007 Dodge Magnum SE 3.5 V6 GAS
- Raise and support vehicle on hoist.
- Mark transmission and axle flanges and rubber couplers for installation alignment.
- Remove crossmember, rear exhaust system and heat shield.
- Remove propeller shaft front and rear coupler-to-flange bolts.
- Remove center bearing mounting bolts.
- Remove propeller shaft with aid of helper. Never allow propeller shaft to hang from center bearing, or while only connected to transmission or rear axle flanges.
- Remove three couple...
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Dodge Magnum AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Trouble Code Identification -> Intermittent & Poor Connections -> Intermittents -> Poor Connections -> Tire Pressure Sensor Check
Vehicle: 2007 Dodge Magnum SXT 3.5 V6 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Trouble Code Identification
Refer to Fig. for diagnostic trouble code identification.
Clearing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector), and follow manufacturer's instructions.
Intermittent & Poor Connections
Intermittents
Most intermittents are caused by faulty electrical connections or wiring. Inspect for the following:
- Wiring broken inside insulation.
- Poor connection between m...
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Dodge Magnum AUTOMOBILES
Alternator, Replace
Vehicle: 2007 Dodge Magnum SXT 3.5 V6 GAS
- Disconnect battery ground cable.
- Rotate belt tensioner counterclockwise until it contacts its stop.
- Remove belt and slowly rotate tensioner into freearm position. Do not let tensioner arm snap back to freearm position.
- Remove bracket mounting bolts.
- Remove alternator upper mounting bolt.
- Raise and suppor...
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Dodge Magnum AUTOMOBILES
Cabin Air Filter Service -> Chrysler LLC -> 2005-09 300, Magnum, 2006-09 Charger & 2008-09 Challenger
Vehicle: 2007 Dodge Magnum SRT8 6.1 V8 GAS
The cabin air filter should be replaced every 12,000 miles.
- Open the hood.
- Remove the passenger side air inlet grille from the cowl panel, Fig. .
- Open the cabin air filter door.
- Remove the cabin air filter from the filter housing...
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Dodge Magnum AUTOMOBILES
Chrysler LLC Cars -> Brake Assist System (BAS) Warning Lamp/Electronic Stability Program (ESP) Warning Lamp -> Charger, Magnum & 300C -> BAS -> ESP/BAS
Vehicle: 2007 Dodge Magnum SE 2.7 V6 GAS
BAS
The yellow Brake Assist System (BAS) fault indicator light in the instrument cluster comes On with the ignition switch in the On position. The light should go out with engine running. If the BAS fault indicator light comes On continuously with engine running, a fault has been detected. If the light stays illuminated, have BAS/ESP system diagnosed and repaired.
ESP/BAS
The yellow fault indicator lamp for the Electronic Stability Progr...
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Dodge Magnum AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2007 Dodge Magnum SE 3.5 V6 GAS
Lower
- Raise and support vehicle.
- Drain cooling system into a suitable container.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator.
- Reposition hose clamp from thermostat housing.
- Remove radiator outlet hose from thermostat housing and fro...
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Dodge Magnum AUTOMOBILES
Serpentine Drive Belt, Replace -> Installation -> Removal
Vehicle: 2007 Dodge Magnum SXT 3.5 V6 GAS
Removal
- Rotate belt tensioner counterclockwise until it contacts a stop.
- Remove belt and slowly rotate tensioner into the freearm position. Do not let tensioner arm snap back to freearm position.
Installation
- Route belt around all pulleys except idler pulley.
- Rotate tensioner arm until it contacts a s...
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Dodge Magnum AUTOMOBILES
Component location diagrams for most 2007 Dodge Magnum cars and light trucks sold in the U.S. from 1990+.
Instrument Panel Diagram for 2007 Dodge Magnum SXT 3.5 V6 GAS Components on diagram: |
Engine Compartment Diagram for 2007 Dodge Magnum R/T 5.7 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Dodge Magnum AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Dodge Magnum cars and light trucks sold in the U.S.
2007 Dodge Magnum R/T 5.7 V8 GAS Wiring Diagram Components on diagram: |
2007 Dodge Magnum SE 3.5 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Dodge Magnum AUTOMOBILES
OEM TSB listings for most 2007 Dodge Magnum cars and light trucks sold in the U.S. from 1985+.
Document: Hard To Fill Or Fuel Nozzle Shuts Off Repeatedly Vehicle: 2007 Dodge Magnum SE 3.5 V6 GAS Auto Systems: |
Document: Chrome Clad Wheel Adapters For Proper Balancing Vehicle: 2007 Dodge Magnum SE 3.5 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Dodge Magnum AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Dodge Magnum cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Dodge Magnum cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Dodge Magnum cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Dodge Magnum cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Dodge Magnum SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Dodge Magnum vehicle. |
Access the Complete guide! |