Auto Parts Search
We have info for following modifications of 2007 GMC Savana 1500
- 2007 GMC Savana 1500 4.3 V6 GAS, CID:262, Fuel Injection, Aspiration:262, Engine VIN:, Desg:X
- 2007 GMC Savana 1500 5.3 V8 GAS, CID:325, Fuel Injection, Aspiration:325, Engine VIN:, Desg:T
- 2007 GMC Savana 1500 5.3 V8 FLEX, CC:5328, CID:325, Fuel Injection, Aspiration:325, Engine VIN:, Desg:Z
- 2007 GMC Savana 1500 LT 5.3 V8 GAS, CID:325, Fuel Injection, Aspiration:325, Engine VIN:, Desg:T
- 2007 GMC Savana 1500 LT 5.3 V8 FLEX, CC:5328, CID:325, Fuel Injection, Aspiration:325, Engine VIN:, Desg:Z
- 2007 GMC Savana 1500 LS 5.3 V8 GAS, CID:325, Fuel Injection, Aspiration:325, Engine VIN:, Desg:T
- 2007 GMC Savana 1500 LS 5.3 V8 FLEX, CC:5328, CID:325, Fuel Injection, Aspiration:325, Engine VIN:, Desg:Z
BRAKE SERVICE PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 GMC Savana 1500 cars and light trucks from 1990+.
Hydraulic Brake Systems -> Brake System Bleed -> Hydraulic System Flush -> Manual Bleed -> Master Cylinder Bleed -> Parking Brake Bleed -> Pressure Bleed
Vehicle: 2007 GMC Savana 1500 LT 5.3 V8 GAS
Manual Bleed
- If vehicle is equipped with power brakes, remove vacuum reserve by applying brakes several times with engine off.
- Fill master cylinder reservoirs with suitable brake fluid. Ensure to always keep master cylinder reservoirs at least half full during entire bleeding procedure.
- If master cylinder is suspected to have air in bore, it must be bled first. To bleed master cylinder, proceed as follows:
- Disconnect forward brake pipe connection at master cylinder.
- Allow brake fluid to fill master cylinder bore until it begins to flow from forward pipe connector port.
- Connect and ...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 GMC Savana 1500 cars and light trucks from 1990+.
Disc Brakes -> Delco Single Piston Sliding Caliper -> Caliper Service -> Assemble -> Disassemble -> Front -> Inspection -> Installation -> Rear -> Removal
Vehicle: 2007 GMC Savana 1500 LT 5.3 V8 GAS
Removal
Front
- Siphon brake fluid out of master cylinder until fluid level is approximately 1/3 full, this will prevent fluid overflow when caliper piston is pushed back into its bore.
- Raise and support vehicle, then remove wheels.
- Push piston back into its bore using suitable C-clamp, Fig. .
- Remove brake caliper hose bolt, then two metal gaskets from brake caliper bolt.
- Remove two caliper mounting bolts and lift caliper off of rotor.
Rear
- Siphon brake fluid out of master cylinder until fluid level is approximately 1/3 full, this will prevent fluid overflow when caliper piston is pushed ...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 GMC Savana 1500 cars and light trucks from 1990+.
Hydraulic Brake Systems -> Component Replacement -> Master Cylinder
Vehicle: 2007 GMC Savana 1500 LS 5.3 V8 GAS
Master Cylinder
- On models equipped with manual brake system,disconnect master cylinder pushrod from brake pedal.
- On all models, disconnect all wire con...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 GMC Savana 1500 cars and light trucks from 1990+.
Disc Brakes -> Delco Single Piston Sliding Caliper -> Rotor, Replace -> 2WD Models -> 4WD Models -> Front -> Rear
Vehicle: 2007 GMC Savana 1500 LT 5.3 V8 FLEX
2WD Models
Front
- Raise and support vehicle.
- Remove tire and wheel assembly.
- Remove caliper as outlined in .
- Remove grease cap from hub/rotor, Fig. .
- Remove cotter pin, nut and washer.
- Remove hub/rotor from spindle, being careful not to damage spindle threads or outer bearing.
- Reverse procedure to install, noting the following:
- Apply high-temperature wheel bearing grease to inner and outer wheel bearings.
- Torque nut to 12 ft. lbs., while turning wheel assembly forward by hand, back nut off one flat or until hole i...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 GMC Savana 1500 cars and light trucks from 1990+.
Disc Brakes -> Delco Single Piston Sliding Caliper -> Rotor, Replace -> 2WD Models -> 4WD Models -> Front -> Rear
Vehicle: 2007 GMC Savana 1500 LS 5.3 V8 FLEX
2WD Models
Front
- Raise and support vehicle.
- Remove tire and wheel assembly.
- Remove caliper as outlined in .
- Remove grease cap from hub/rotor, Fig. .
- Remove cotter pin, nut and washer.
- Remove hub/rotor from spindle, being careful not to damage spindle threads or outer bearing.
- Reverse procedure to install, noting the following:
- Apply high-temperature wheel bearing grease to inner and outer wheel bearings.
- Torque nut to 12 ft. lbs., while turning wheel assembly forward by hand, back nut off one flat or until hole i...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2007 GMC Savana 1500 AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2007 GMC Savana 1500 cars and light trucks from 1990+.
Disc Brakes -> Delco Dual Piston Sliding Caliper -> Precautions -> Brake Disc Service -> Brake Lines & Linings -> Brake Roughness -> General
Vehicle: 2007 GMC Savana 1500 5.3 V8 FLEX
Brake Lines & Linings
Remove one of the front wheels and inspect the brake disc, caliper and linings.
Do not allow any oil or grease on the linings. It is recommended that linings be replaced in sets when worn or damaged.
If the caliper is cracked or fluid leakage through the casting is evident, it must be replaced as a unit.
Brake Roughness
The most common cause of brake chatter on disc brakes is a variation in thickness of the disc. If roughness or vibration is encountered during highway operation or if pedal pumping is experienced at low speeds, the disc may have excessive thickness v...
CLICK HERE TO GET FULL ACCESS TO 2007 GMC Savana 1500 BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 GMC Savana 1500 vehicle. |
Access the Complete guide! |