Auto Parts Search
2007 Volvo V50 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Volvo REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Volvo V50 AUTOMOBILES
CV AXLE SHAFT, Replace -> Left Side -> Right Side
Vehicle: 2007 Volvo V50 T5 2.5 L5 GAS
Left Side
- Raise and support vehicle on lift.
- Remove hub cap.
- Remove front wheel lug nuts.
- Remove bolt for wheel hub driveshaft.
- Tap end of drive shaft approximately 15-20mm into wheel hub.
- Remove anti-roll bar strut from spring strut.
- Counterhold ball joint pinion so that ball joint boot cannot turn.
- Detach brake hose from its mounting lug in spring strut.
- Detach ABS line from its mounting lug in wheel arch.
- Slacken off nut for ball joint for control arm. Before removing the nuts from the ball joints, clean the exposed threads of rust. Lubricate using rust solvent before removing t...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V50 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Volvo V50 AUTOMOBILES
Reset Procedures
Vehicle: 2007 Volvo V50 2.4I 2.4 L5 GAS
If the system detects low tire pressure, a warning message will be displayed on the instrument panel and the tire pressure warning lamp will be illuminated. Inflating tire to recommended pressure and driving the vehicle at a speed of 20 mph or faster for several minutes will clear the tire message.
Volvo recommends that all ...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V50 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Volvo V50 AUTOMOBILES
Alternator, Replace
Vehicle: 2007 Volvo V50 T5 2.5 L5 GAS
- Disconnect battery ground cable.
- Remove bolts for intake manifold front cover plate air cleaner module.
- Remove vacuum hose to MAF sensor and disconnect electrical connector.
- Disconnect brake vacuum hose from intake manifold.
- Disconnect vacuum hose from vacuum pump then move hoses to one side.
- Remove tie straps for cable harness on air cleaner module.
- Remove screw holding cable harness and move cable harness below air cleaner module.
- Remove bolt securing oil dipstick tube.
- Detach hose clamp for rubber hose on electronic throttle module then move hose to one side.
- Remove bolts for elec...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V50 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Volvo V50 AUTOMOBILES
Cabin Air Filter Service -> Volvo -> 2005-09 S40, V50 & 2006-09 C70
Vehicle: 2007 Volvo V50 2.4I 2.4 L5 GAS
The cabin air filter should be replaced every 15,000 miles. The filter should be replaced more often if air flow is less than normal.
- Remove the four hidden instrument panel center cover clips, then the cover, Fig. .
- Using a weather strip tool, or other suitable tool, remove the left instrument panel end cover. Use care not to damage the cover during removal.
- From the left end of the instrument panel, remove the sound proofing panel retaining clip, Fig. .
- Remove the three driver side sound proofing panel retaining screws, Fig. .
- Detach the in-car temperature sensor fro...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V50 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Volvo V50 AUTOMOBILES
Volvo -> Service Indicator Lamp -> 2005-09 V50
Vehicle: 2007 Volvo V50 T5 2.5 L5 GAS
- Turn ignition Off.
- Depress trip odometer Reset button, then place the ignition switch in the On position within 2 seconds.
- Hold the reset button for the trip odometer pressed in until the original value has been reset .
- The information lamp will light when the reset button must be released.
- Re...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V50 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Volvo V50 AUTOMOBILES
Radiator, Replace
Vehicle: 2007 Volvo V50 T5 2.5 L5 GAS
- Drain coolant into suitable container.
- Remove electric cooling fan.
- Remove charge air cooler.
- Remove engine compartment panel.
- Remove radiator mounting on both sides.
- Slightly raise condenser and suspend from a suitable place, so ...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V50 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Volvo V50 AUTOMOBILES
Serpentine Drive Belt, Replace -> Inner Drive Belt -> Outer Drive Belt
Vehicle: 2007 Volvo V50 2.4I 2.4 L5 GAS
Outer Drive Belt
- Raise and support vehicle.
- Remove right front wheel and tire.
- Remove right fender liner. Remove screws at front edge and fold back fender liner.
- Rotate belt tensioner clockwise as far as it will go, using a suitable tool to relieve tension from drive belt.
- Remove ou...
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V50 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Volvo V50 AUTOMOBILES
Component location diagrams for most 2007 Volvo V50 cars and light trucks sold in the U.S. from 1990+.
Communication Components Diagram for 2007 Volvo V50 2.4I 2.4 L5 GAS Components on diagram: |
Exterior Lights Diagram for 2007 Volvo V50 2.4I 2.4 L5 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V50 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Volvo V50 AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Volvo V50 cars and light trucks sold in the U.S.
2007 Volvo V50 2.4I 2.4 L5 GAS Wiring Diagram Components on diagram: |
2007 Volvo V50 T5 2.5 L5 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V50 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Volvo V50 AUTOMOBILES
OEM TSB listings for most 2007 Volvo V50 cars and light trucks sold in the U.S. from 1985+.
Document: HIGH OIL CONSUMPTION SI6 NON-TURBO Vehicle: 2007 Volvo V50 2.4I 2.4 L5 GAS Auto Systems: |
Document: DIFFERENTIAL ELECTRONIC MODULE (DEM), SOFTWARE (SW) - REVISED Vehicle: 2007 Volvo V50 T5 2.5 L5 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V50 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Volvo V50 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Volvo V50 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Volvo V50 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Volvo V50 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Volvo V50 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Volvo V50 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Volvo V50 vehicle. |
Access the Complete guide! |