Auto Parts Search
2008 Dodge Sprinter 2500 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Dodge REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service

BRAKE SERVICE PROCEDURES FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
Disc Brakes -> Description
Vehicle: 2008 Dodge Sprinter 2500 3.5 V6 GAS
These vehicles are equipped with dual piston calipers, sliding single piston systems, single non-metallic calipers, floating caliper-single piston or single piston caliper mounted disc brake systems.
Upon brake application, fluid pressure exerted against the caliper piston increases equally in all directions, creating the same pressure in the caliper bore and on the piston.
Press...
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
DaimlerChrysler Corp./Jeep Light Trucks, SUVs & Vans -> Fuel Filter Replacement -> Sprinter
Vehicle: 2008 Dodge Sprinter 2500 3.5 V6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its ada...
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble -> U-Joint with Injected Rings -> U-Joint with Snap Rings
Vehicle: 2008 Dodge Sprinter 2500 3.0 V6 DIESEL
This procedure describes a propeller shaft equipped with a cardan joint in the tube yoke. For propeller shafts equipped with a companion/slip yoke, repeat the steps to remove the remaining cardan joint.
U-Joint with Snap Rings
Disassemble
- Tap outside of bearing cap with a drift to loosen snap ring.
- Remove snap rings from both sides of yoke.
- Position yoke with grease fitting if equipped, pointing up.
- Position a socket with a inside diameter large enough to receive bearing cap, beneath yoke on a press.
- Place another socket with an outside diameter smaller than bearing cap on ...
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
Component Replacement -> Front -> Installation -> Rear -> Removal -> Tire Pressure Sensor -> TPMS Transponder
Vehicle: 2008 Dodge Sprinter 2500 3.0 V6 DIESEL
Tire Pressure Sensor
The cap used on this valve stem contains an O-ring seal to prevent contamination and moisture from entering the valve stem. Retain this valve stem cap for reuse. Do not substitute a regular valve stem cap in its place.
The valve stem used on this vehicle is made of aluminum and the core is nickel plated brass. The original valve stem core must be reinstalled and not substituted with a valve stem core made of a different material. This is required to prevent corrosion in the valve stem caused by the different metals.
Removal
- Loosen the wheel lug nuts.
- Raise...
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
Alternator, Replace
Vehicle: 2008 Dodge Sprinter 2500 3.0 V6 DIESEL
- Disconnect battery ground cable.
- Rotate or lift belt tensioner arm, using a suitable tool to relieve tension from drive belt.
- Remove alternator drive belt.
- Raise and support vehicle.
- Unsnap plastic insulator cap from B+ output terminal.
- Remove B+ terminal mounting nut at rear of alterna...
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
Cabin Air Filter Service -> Chrysler LLC -> 2007-09 Sprinter -> Front Cabin Air Filter -> Rear Cabin Air Filter
Vehicle: 2008 Dodge Sprinter 2500 3.0 V6 DIESEL
On models less Assyst Maintenance Computer, cabin air filter element should be replaced every 30,000 miles. The filter should be replaced more often if air flow is less than normal.
On models with Assyst Maintenance Computer, cabin air filter element should be replaced when two wrench symbols are indicated on the instrument panel maintenance display panel. The filter should be replaced more often if air flow is less than normal.
Front Cabin Air Filter
- Open the hood.
- Detach the retaining tabs securing the cabin air filter to the fresh air inlet housing located in the engine compartm...
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
Chrysler LLC Trucks -> Check Gauge Warning Lamp ->
Vehicle: 2008 Dodge Sprinter 2500 3.0 V6 DIESEL
When the ignition is turned On, the lamp will light for approximately 2 seconds as a bulb inspection. The PCM continually monitors the engine oil pressure, engine coolant temperature and electrical system voltage. The check gauges lamp w...
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2008 Dodge Sprinter 2500 3.0 V6 DIESEL
Lower
- Raise and support vehicle.
- Drain cooling system into a suitable container.
- Reposition hose clamp from radiator.
- Remove radiator outlet hose from radiator.
- Reposition hose clamp from water inlet tube.
- Remove radiator outlet hose from water inlet tube and from vehicle.
- Reve...
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2008 Dodge Sprinter 2500 3.0 V6 DIESEL
- Remove radiator fan and shroud. Radiator fan assembly is attached (threaded) to the water pump hub shaft. Remove the fan blade/viscous fan drive assembly from the water pump by turning the mounting nut countercl...
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
Component location diagrams for most 2008 Dodge Sprinter 2500 cars and light trucks sold in the U.S. from 1990+.
![]() Components on diagram: |
![]() Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
OEM drawn wiring diagrams for most 2008 Dodge Sprinter 2500 cars and light trucks sold in the U.S.
![]() Components on diagram: |
![]() Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
OEM TSB listings for most 2008 Dodge Sprinter 2500 cars and light trucks sold in the U.S. from 1985+.
Document: RUST AND OR CORROSION ON QUARTER PANEL ABOVE TAILLAMP Vehicle: 2008 Dodge Sprinter 2500 3.0 V6 DIESEL Auto Systems: |
Document: EMISSIONS RECALL H44 - REPROGRAM ECM - EGR SYSTEM Vehicle: 2008 Dodge Sprinter 2500 3.0 V6 DIESEL Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2008 Dodge Sprinter 2500 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2008 Dodge Sprinter 2500 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2008 Dodge Sprinter 2500 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2008 Dodge Sprinter 2500 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2008 Dodge Sprinter 2500 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2008 Dodge Sprinter 2500 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
![]() |
Access the Complete guide! |