Auto Parts Search
2008 Volvo C70 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Volvo REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2008 Volvo C70 AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2008 Volvo C70 T5 2.5 L5 GAS
Take care not to damage the sealing ring in the transmission or the boot on the drive shaft.
- Raise and support vehicle.
- Remove wheel lug nuts.
- Remove ABS sensor.
- Unhook bracket for brake line and ABS wiring and let it hang free.
- Insert suitable tool into brake rotor vanes and caliper to prevent hub from turning.
- Remove axle shaft nut from hub.
- Tap end of shaft inward approximately 10-15mm, using rubber or copper mallet.
- Remove bolt and nut securing lower ball joint to knuckle.
- Separate ball joint from knuckle using suitable tool.
- Install protective cap onto ball joint.
- Install suppo...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo C70 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2008 Volvo C70 AUTOMOBILES
Wiring Diagrams
Vehicle: 2008 Volvo C70 T5 2.5 L5 GAS
Refer to F...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo C70 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2008 Volvo C70 AUTOMOBILES
Alternator, Replace
Vehicle: 2008 Volvo C70 T5 2.5 L5 GAS
- Disconnect battery ground cable.
- Remove bolts for intake manifold front cover plate air cleaner module.
- Remove vacuum hose to MAF sensor and disconnect electrical connector.
- Disconnect brake vacuum hose from intake manifold.
- Disconnect vacuum hose from vacuum pump then move hoses to one side.
- Remove tie straps for cable harness on air cleaner module.
- Remove screw holding cable harness and move cable harness below air cleaner module.
- Remove bolt securing oil dipstick tube.
- Detach hose clamp for rubber hose on electronic throttle module then move hose to one side.
- Remove bolts for elec...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo C70 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2008 Volvo C70 AUTOMOBILES
Cabin Air Filter Service -> Volvo -> 2005-09 S40, V50 & 2006-09 C70
Vehicle: 2008 Volvo C70 T5 2.5 L5 GAS
The cabin air filter should be replaced every 15,000 miles. The filter should be replaced more often if air flow is less than normal.
- Remove the four hidden instrument panel center cover clips, then the cover, Fig. .
- Using a weather strip tool, or other suitable tool, remove the left instrument panel end cover. Use care not to damage the cover during removal.
- From the left end of the instrument panel, remove the sound proofing panel retaining clip, Fig. .
- Remove the three driver side sound proofing panel retaining screws, Fig. .
- Detach the in-car temperature sensor fro...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo C70 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2008 Volvo C70 AUTOMOBILES
Volvo -> Air Bag Warning Lamp ->
Vehicle: 2008 Volvo C70 T5 2.5 L5 GAS
If the Air Bag warning lamp lights and stays on, diagnosis and ...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo C70 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2008 Volvo C70 AUTOMOBILES
Radiator, Replace
Vehicle: 2008 Volvo C70 T5 2.5 L5 GAS
- Drain coolant into suitable container.
- Remove electric cooling fan.
- Remove charge air cooler.
- Remove engine compartment panel.
- Remove radiator mounting on both sides.
- Slightly raise condenser and suspend from a suitable place, so ...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo C70 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2008 Volvo C70 AUTOMOBILES
Serpentine Drive Belt, Replace -> Inner Drive Belt -> Outer Drive Belt
Vehicle: 2008 Volvo C70 T5 2.5 L5 GAS
Outer Drive Belt
- Raise and support vehicle.
- Remove right front wheel and tire.
- Remove right fender liner. Remove screws at front edge and fold back fender liner.
- Rotate belt tensioner clockwise as far as it will go, using a suitable tool to relieve tension from drive belt.
- Remove ou...
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo C70 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2008 Volvo C70 AUTOMOBILES
Component location diagrams for most 2008 Volvo C70 cars and light trucks sold in the U.S. from 1990+.
Body Components Diagram for 2008 Volvo C70 T5 2.5 L5 GAS Components on diagram: |
Engine Compartment Diagram for 2008 Volvo C70 T5 2.5 L5 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo C70 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2008 Volvo C70 AUTOMOBILES
OEM drawn wiring diagrams for most 2008 Volvo C70 cars and light trucks sold in the U.S.
2008 Volvo C70 T5 2.5 L5 GAS Wiring Diagram Components on diagram: |
2008 Volvo C70 T5 2.5 L5 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo C70 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2008 Volvo C70 AUTOMOBILES
OEM TSB listings for most 2008 Volvo C70 cars and light trucks sold in the U.S. from 1985+.
Document: DIFFERENTIAL ELECTRONIC MODULE (DEM), SOFTWARE (SW) - REVISED Vehicle: 2008 Volvo C70 T5 2.5 L5 GAS Auto Systems: |
Document: NOISE FROM FRONT ROOF LOCK BRACES Vehicle: 2008 Volvo C70 T5 2.5 L5 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo C70 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2008 Volvo C70 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2008 Volvo C70 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2008 Volvo C70 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2008 Volvo C70 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2008 Volvo C70 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2008 Volvo C70 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2008 Volvo C70 vehicle. |
Access the Complete guide! |