Auto Parts Search
2009 Chevrolet Express 1500 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Chevrolet Express 1500 AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble
Vehicle: 2009 Chevrolet Express 1500 LS 5.3 V8 FLEX
Never clamp propeller shaft tubing in a vise. Clamping could dent or deform the tube causing an imbalance or unsafe condition. Always clamp on one of the yokes and support the shaft horizontally. Avoid damaging the slip yoke sealing surface. Nicks may damage the bushing or cut the lip seal.
Disassemble
- Support propeller shaft in a line horizontal with table of a press.
- Mark propeller shaft in order to show which end connects to transmission and which end goes to rear axle.
- On models equipped with external snap ring retainers, proceed as follows:
- Disassemble snap rings by ...
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Express 1500 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Chevrolet Express 1500 AUTOMOBILES
Wiring Diagrams -> Wire Color Code Identification
Vehicle: 2009 Chevrolet Express 1500 4.3 V6 GAS
Refer to Figs. through for w...
[[table data]]CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Express 1500 TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Chevrolet Express 1500 AUTOMOBILES
Alternator, Replace
Vehicle: 2009 Chevrolet Express 1500 4.3 V6 GAS
- Disconnect battery ground cable.
- Remove drive belt.
- Unbolt and reposition oil level indicator tube.
- Unbolt and reposition oil fill tube.
- Disconnect engine wiring harness electrical connector from alternator.
- Remove oil fill tube bracket stud.
- Reposition engine wiring harness clip.
- Reposition positive battery cable boot at alternator.
- Remove alternator nut.
- Remove positive batte...
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Express 1500 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Chevrolet Express 1500 AUTOMOBILES
General Motors Corp./Saturn Trucks -> Check Engine/Service Engine Soon Indicator Lamp -> Electronic Engine Controls Or Electronic Fuel Injection Except Tracker
Vehicle: 2009 Chevrolet Express 1500 4.3 V6 GAS
The Check Engine/Service Engine Soon Lamp should light when the ignition is turned On. When the engine is started, the lamp should go off. If the lamp remains on for 10 seconds or constantly after the engine is started, the self diagnosis system has detected a problem and has stored a code in the system Electronic Control Module (ECM) or Powertrain Control Module (PCM). After diagnosis and repair, the ECM/PCM memory can be cleared of codes either by using a scan tool (OBD II systems) or by disconnecting the battery ground ca...
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Express 1500 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Chevrolet Express 1500 AUTOMOBILES
Radiator, Replace
Vehicle: 2009 Chevrolet Express 1500 LS 5.3 V8 FLEX
- Drain cooling system into a suitable container.
- Remove air cleaner assembly.
- Remove coolant recovery reservoir.
- Remove clamp at radiator inlet using hose clamp pliers tool J 38185.
- Remove radiator inlet hose from radiator.
- Remove outlet heater hose clamp at radiator using hose clamp pliers tool J 38185.
- Remove outlet heater hose from radiator.
- Remove automatic transmiss...
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Express 1500 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Chevrolet Express 1500 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Chevrolet Express 1500 4.3 V6 GAS
These engines use a single serpentine drive belt to drive all engine-mount accessories. All belt drive accessories are rigidly mounted with belt tension maintained by a spring loaded automatic tensioner.
- Rotate tensioner counterclockwise using suitable 1/2 inch break...
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Express 1500 SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Chevrolet Express 1500 AUTOMOBILES
OEM TSB listings for most 2009 Chevrolet Express 1500 cars and light trucks sold in the U.S. from 1985+.
Document: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE Vehicle: 2009 Chevrolet Express 1500 4.3 V6 GAS Auto Systems: |
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2009 Chevrolet Express 1500 4.3 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Express 1500 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Chevrolet Express 1500 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Chevrolet Express 1500 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Chevrolet Express 1500 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Chevrolet Express 1500 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Chevrolet Express 1500 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Chevrolet Express 1500 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Chevrolet Express 1500 vehicle. |
Access the Complete guide! |