Auto Parts Search
2009 Dodge Journey CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Dodge REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Dodge Journey AUTOMOBILES
DRIVESHAFT, Replace
Vehicle: 2009 Dodge Journey SE 2.4 L4 GAS
- Raise and support vehicle.
- Remove tire and wheel assembly.
- Drain differential carrier oil into suitable container.
- Mark rear propeller shaft and differential, Fig. , for proper installation.
- Remove rear propeller shaft to rear axle retaining nuts.
- Remove three bolts from center support heat shield, then heat shield.
- Remove center support mount...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge Journey DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Dodge Journey AUTOMOBILES
Relearn Procedures
Vehicle: 2009 Dodge Journey SXT 3.5 V6 GAS
When a tire pressure sensor has been replaced, the WIN will learn and store the sensor ID when the vehicle is driven continuously above 15 mph for 10 minutes. A new sensor ID can also be programmed directly into the WCM using a suitably ...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge Journey TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Dodge Journey AUTOMOBILES
Alternator, Replace
Vehicle: 2009 Dodge Journey R/T 3.5 V6 GAS
- Disconnect battery ground cable.
- Remove alternator drive belt.
- Unsnap plastic insulator cap from B+ output terminal.
- Remove B+ terminal mounting nut at rear of alternator. Disconnect terminal from alternator.
- Disconnect field wire connector at rear of alternator by pushing on connector tab.
- Remove short mounting bol...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge Journey STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2009 Dodge Journey AUTOMOBILES
Cabin Air Filter Service -> Chrysler LLC -> 2009 Journey
Vehicle: 2009 Dodge Journey R/T 3.5 V6 GAS
The cabin air filter should be replaced every 12,000 miles.
- Open the glove compartment.
- Push inward on the sides of the glove compartment bin, then lower the door.
- Pivot the glove compartment downward and detach the hooks from the instrument panel.
- Remove the glove compartment.
- Release the two tabs retaining the cabin air filter cover to the A/C-heater housing, then remove the cover, Fig. .
- Remove the cabin air filter element from the A/C-heater housing, Fig. .
- Install the cabin air filter element into the A/C-heater housing. If the filter is equipped with air flow directio...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge Journey CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Dodge Journey AUTOMOBILES
Chrysler LLC Trucks -> Check Engine Lamp -> Chrysler, Dodge, Jeep & Plymouth Except Ram 50
Vehicle: 2009 Dodge Journey SXT 3.5 V6 GAS
On models less OBD II, the Check Engine lamp should light for approximately 3 seconds after the ignition has been turned On as a bulb inspection. If improper or no signals are received by the Powertrain Control Module (PCM) from various sensors and monitored systems or if the PCM enters its Limp-In mode, the PCM will light the Check Engine lamp. On Chrysler, Dodge and Plymouth models, After diagnosing and servicing the vehicle, the PCM memory will be cleared after approximately 40 to 100 ignition key On-Off cycles or by using a suitable scan tool. ...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge Journey MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Dodge Journey AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2009 Dodge Journey SXT 3.5 V6 GAS
Lower
- Drain cooling system into a suitable container.
- Reposition hose clamp at radiator outlet and remove hose.
- Reposition hose clamp at water inlet pipe and remove hose.
- Remove hose from vehicle.
- Reverse procedure to install.
Upper
- Drain cooling system into ...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge Journey RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Dodge Journey AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Dodge Journey SE 2.4 L4 GAS
- Disconnect battery ground cable from battery.
- Rotate accessory drive belt tensioner counterclockwise using ...
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge Journey SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Dodge Journey AUTOMOBILES
OEM TSB listings for most 2009 Dodge Journey cars and light trucks sold in the U.S. from 1985+.
Document: RECALL - Emissions Recall J23 - Replace Powertrain Control Module Vehicle: 2009 Dodge Journey SE 2.4 L4 GAS Auto Systems: |
Document: Hard To Fill Or Fuel Nozzle Shuts Off Repeatedly Vehicle: 2009 Dodge Journey SXT 3.5 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge Journey TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Dodge Journey AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Dodge Journey cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Dodge Journey cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Dodge Journey cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Dodge Journey cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Dodge Journey SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Dodge Journey vehicle. |
Access the Complete guide! |