Auto Parts Search
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 1993 BMW 325IC car and truck
repair procedures including BMW engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your 1993 BMW 325IC automobile. Try the Automotix DIY solution today!
BRAKE SERVICE PROCEDURES FOR 1993 BMW 325IC AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 BMW 325IC cars and light trucks from 1990+.
Disc Brakes -> Brake Pad Service -> 318 & 325 -> Except 318 & 325 -> Front Brake Pads, Replace -> Rear Brake Pads, replace
Vehicle: 1993 BMW 325IC 2.5 L6 GAS
Front Brake Pads, Replace
318 & 325
- Raise and support vehicle, then remove front wheels.
- Remove brake pad wear indicator connector from left side of caliper.
- Remove anti-rattle clip, then the caliper sliding bolt plastic caps.
- Lift brake hose out of holder, then remove caliper sliding bolts.
- Remove caliper toward rear. Remove brake pads, then suspend caliper from frame with wire.
- Reverse procedure to install, noting the following:
- Compress caliper piston into bore.
- Check fluid level and bleed brake system as necessary.
- Tighten to specifications.
Except 318 & 325
- Remove wheels and disconne...
CLICK HERE TO GET FULL ACCESS TO 1993 BMW 325IC BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 BMW 325IC AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 BMW 325IC cars and light trucks from 1990+.
Hydraulic Brake Systems -> Brake System Bleed
Vehicle: 1993 BMW 325IC 2.5 L6 GAS
- Connect suitable pressure bleeder to brake fluid reservoir. Maximum charging pressure is 43.5 psi.
- Attach bleeder hose and container to right rear wheel. Bleed until no bubbles appear.
- Repeat step 2 for left rear, right front and left front wheels.
- Support rear suspension at wheel carriers and lower car so rear suspension compresses to its normal loaded position (to prevent damage to output shaft joints). Wheels must be able to turn freely.
- Attach...
CLICK HERE TO GET FULL ACCESS TO 1993 BMW 325IC BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 BMW 325IC AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 BMW 325IC cars and light trucks from 1990+.
Anti-lock Brakes -> System Service -> Brake System Bleed -> Component Replacement -> Control Unit, Replace -> Front Speed Sensor, Replace -> Hydraulic Unit, Replace -> Rear Speed Sensor, Replace
Vehicle: 1993 BMW 325IC 2.5 L6 GAS
Brake System Bleed
Refer to "Hydraulic Brake Systems," for procedures.
Component Replacement
Hydraulic Unit, Replace
- Disconnect battery ground cable.
- Remove coolant expansion tank.
- Remove brake lines from hydraulic unit as follows: front left; front right; rear left; rear right.
- Remove brake hydraulic lines from master cylinder to hydraulic unit.
- Remove cover from top of hydraulic cover, then loosen, but do not remove, bolts for hydraulic unit.
- Remove retaining screws and pull off multiple pin connector and disconnect ground wire.
- Pull up on the front of the hydraulic unit, then disconnect t...
CLICK HERE TO GET FULL ACCESS TO 1993 BMW 325IC BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 BMW 325IC AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 BMW 325IC cars and light trucks from 1990+.
Disc Brakes -> Caliper Service -> Caliper Overhaul -> Caliper, Replace -> Front -> Rear
Vehicle: 1993 BMW 325IC 2.5 L6 GAS
Caliper, Replace
Front
- Raise and support vehicle, then remove front wheel.
- Drain a moderate amount of brake fluid from reservoir with a syringe.
- Disconnect caliper brake hose.
- Remove caliper bolts and disconnect brake pad wear sensor electrical connector, if necessary.
- Remove caliper toward rear.
- Reverse procedure to install, noting the following:
- Tighten bolts to specifications.
- Bleed brake system.
- Ensure brake pad wear sensor wire does not contact rotor or wheel.
Rear
- Raise and support vehicle, then remove wheel.
- Drain a moderate amount of brake fluid from reservoir with a syringe.
- Disconne...
CLICK HERE TO GET FULL ACCESS TO 1993 BMW 325IC BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 BMW 325IC AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 BMW 325IC cars and light trucks from 1990+.
Anti-lock Brakes -> Troubleshooting
Vehicle: 1993 BMW 325IC 2.5 L6 GAS
Refer to "Diagno... "
CLICK HERE TO GET FULL ACCESS TO 1993 BMW 325IC BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1993 BMW 325IC AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1993 BMW 325IC cars and light trucks from 1990+.
Anti-lock Brakes -> Diagnosis & Testing -> 318 and 325 -> 525, 535, 735 & 750 -> Diagnostic Tests
Vehicle: 1993 BMW 325IC 2.5 L6 GAS
The electronic control unit monitors the Anti-Lock Brake System (ABS) constantly. The system must be checked when the ABS indicator lamp does not go out, comes on while driving or does not come on when ignition is turned on. A BMW service tester ...
[[table data]] [[table data]]CLICK HERE TO GET FULL ACCESS TO 1993 BMW 325IC BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
| More parts |
