Auto Parts Search
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 1999 Ford E-150 Econoline car and truck
repair procedures including Ford engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your 1999 Ford E-150 Econoline automobile. Try the Automotix DIY solution today!
We have info for following modifications of 1999 Ford E-150 Econoline
- 1999 Ford E-150 Econoline 4.6 V8 GAS, CID:281, Fuel Injection, Aspiration:281, Engine VIN:, Desg:W
- 1999 Ford E-150 Econoline 4.6 V8 GAS, CID:281, Fuel Injection, Aspiration:281, Engine VIN:, Desg:6
- 1999 Ford E-150 Econoline 4.2 V6 GAS, CID:256, Fuel Injection, Aspiration:256, Engine VIN:, Desg:2
- 1999 Ford E-150 Econoline 5.4 V8 GAS, CID:330, Fuel Injection, Aspiration:330, Engine VIN:, Desg:L
BRAKE SERVICE PROCEDURES FOR 1999 Ford E-150 Econoline AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1999 Ford E-150 Econoline cars and light trucks from 1990+.
Disc Brakes -> Rotor Replacement -> Aerostar -> Dana -> E-Series -> Escape -> Expedition, Navigator, F-150 & F-250LD -> Explorer, Mountaineer & Ranger -> F-Super Duty Series -> Ford -> Front -> Installation -> Rear -> Removal -> Windstar & Villager
Vehicle: 1999 Ford E-150 Econoline 5.4 V8 GAS
Aerostar
Removal
- Remove sufficient brake fluid from master cylinder reservoir.
- Raise and support vehicle, then remove tire and wheel assembly.
- Remove disc brake caliper as outlined in "Caliper Service".
- On models equipped with 2WD, remove hub grease cap, cotter pin, nut retainer, hub spindle nut and front outer wheel bearing washer, then remove outer wheel bearing.
- On all models, remove front disc brake hub and rotor.
- On models equipped with 4WD, remove hub as outlined under "Halfshaft, Replace," in "All Wheel Drive System."
Installation
- On models equipped with 2WD, install front disc brake ...
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-150 Econoline BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1999 Ford E-150 Econoline AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1999 Ford E-150 Econoline cars and light trucks from 1990+.
Disc Brakes -> Troubleshooting -> Brake Noise -> Brake Pedal Eases Down Slowly -> Brake Pedal Goes Down Fast -> Brakes Drag -> Brakes Lock Up During Light Brake Pedal Force -> Brakes Pull Or Drift -> Excessive Brake Pedal Effort -> Excessive Or Erratic Brake Pedal Travel -> Red Brake Warning Indicator Always On
Vehicle: 1999 Ford E-150 Econoline 4.6 V8 GAS
Brakes Pull Or Drift
- Tire air pressure.
- Wheel alignment.
- Brake pads, shoes or linings.
- Brake or suspension components.
Red Brake Warning Indicator Always On
- Instrument cluster.
- Warning indicator circuit.
- Parking brake.
- Brake fluid level.
Brake Pedal Goes Down Fast
- Brake fluid level.
- Air in system.
- Brake master cylinder malfunction.
- Normal RABS or ABS function.
Brake Pedal Eases Down Slowly
- Air in system.
- Brake master cylinder malfunction.
- Normal RABS or ABS function.
Brakes Lock Up During Light Brake Pedal Force
- Disc or drum brake component.
- Parking brake com...
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-150 Econoline BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1999 Ford E-150 Econoline AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1999 Ford E-150 Econoline cars and light trucks from 1990+.
Anti-lock Brakes -> Aerostar, E-Series, F-Series & Ranger (RABS) -> System Service -> 1997 F-250HD & F-350 -> Aerostar -> Aerostar & 1997 Ranger -> Brake System Bleed -> Component Replacement -> E-Series -> Except Aerostar & 1997 Ranger -> F-150 & F-250LD -> F-Super Duty Series -> Installation -> RABS Module -> Ranger -> Rear Wheel Speed Sensor -> Removal -> Speed Sensor Ring
Vehicle: 1999 Ford E-150 Econoline 4.6 V8 GAS
Brake System Bleed
Aerostar & 1997 Ranger
The RABS II master cylinder and hydraulic control unit must be bled using anti-lock brake adapter tool No. T90P-50-ALA and jumper tool No. T93T-50-ALA, or equivalents. If this procedure is not followed, air will be trapped in the hydraulic control unit and will contribute to improper brake pedal feel.
Bleed system as follows:
- Place bleed/harness switch on bleed adapter tool to bleed position.
- Turn ignition switch to On position. At this point, the red OFF indicator should turn on.
- Push motor button on the adapter down. This starts the pump moto...
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-150 Econoline BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1999 Ford E-150 Econoline AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1999 Ford E-150 Econoline cars and light trucks from 1990+.
Drum Brakes -> Expedition, Explorer, E-150, F-150, F-250LD, Mountaineer, Navigator & Ranger -> Adjustments -> Drums Installed -> Drums Removed -> Expedition, Explorer, F-150, F-250LD, Mountaineer & Navigator -> Parking Brake Except Rear Disc -> Parking Brake w/Rear Disc -> Service Brake
Vehicle: 1999 Ford E-150 Econoline 4.6 V8 GAS
Service Brake
The rear brake shoes adjust automatically when the vehicle is driven in reverse and the brakes are applied sharply several times. Manual adjustment is required only when brake shoes are replaced. When adjusting rear brakes, ensure parking brake is properly adjusted and adjuster is operating freely.
Drums Removed
- With drums removed, clean areas where shoes contact backing plate, then apply suitable lubricant to contact areas. Ensure lubricant does not contaminate linings.
- Adjust gauge to inside diameter of brake drum using suitable brake shoe adjusting gauge.
- Reverse tool an...
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-150 Econoline BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1999 Ford E-150 Econoline AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1999 Ford E-150 Econoline cars and light trucks from 1990+.
Disc Brakes -> Troubleshooting -> Brake Noise -> Brake Pedal Eases Down Slowly -> Brake Pedal Goes Down Fast -> Brakes Drag -> Brakes Lock Up During Light Brake Pedal Force -> Brakes Pull Or Drift -> Excessive Brake Pedal Effort -> Excessive Or Erratic Brake Pedal Travel -> Red Brake Warning Indicator Always On
Vehicle: 1999 Ford E-150 Econoline 4.6 V8 GAS
Brakes Pull Or Drift
- Tire air pressure.
- Wheel alignment.
- Brake pads, shoes or linings.
- Brake or suspension components.
Red Brake Warning Indicator Always On
- Instrument cluster.
- Warning indicator circuit.
- Parking brake.
- Brake fluid level.
Brake Pedal Goes Down Fast
- Brake fluid level.
- Air in system.
- Brake master cylinder malfunction.
- Normal RABS or ABS function.
Brake Pedal Eases Down Slowly
- Air in system.
- Brake master cylinder malfunction.
- Normal RABS or ABS function.
Brakes Lock Up During Light Brake Pedal Force
- Disc or drum brake component.
- Parking brake com...
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-150 Econoline BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 1999 Ford E-150 Econoline AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 1999 Ford E-150 Econoline cars and light trucks from 1990+.
Disc Brakes -> Tightening Specifications
Vehicle: 1999 Ford E-150 Econoline 4.6 V8 GAS
CLICK HERE TO GET FULL ACCESS TO 1999 Ford E-150 Econoline BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
| More parts |
| Get the Complete Technical Service Bulletins! |
 Access diagrams and repair information such as wiring diagrams,
diagnosis and repair charts, manufacturer
service bulletins, and OEM Part
numbers of your 1999 Ford E-150 Econoline vehicle.
|
| Access the Complete guide! |
