Auto Parts Search
2000 Plymouth Neon CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Plymouth REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2000 Plymouth Neon AUTOMOBILES
Air Bag System Precautions -> DaimlerChrysler -> Disarming -> 1990-97 -> 1994-96 Cherokee -> 1998-2004 -> Except 1994-96 Cherokee -> Light Trucks & Vans -> Passenger Cars
Vehicle: 2000 Plymouth Neon 2.0 L4 GAS
Passenger Cars
1990-97
It may be required to access and record all Diagnostic Trouble Codes (DTCs) prior to disarming the air bag system.
- Place ignition switch in Lock position.
- Disconnect and isolate battery ground cable.
- Wait at least two minutes after disconnecting battery ground cable before doing any further work on vehicle. The air bag system is designed to retain enough voltage to deploy air bags for a short time even after battery has been disconnected.
1998-2004
It may be required to access and rec...
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2000 Plymouth Neon AUTOMOBILES
Drum Brakes -> Type 1 -> Inspection -> Adjuster Mechanism -> Backing Plate -> Brake Drums -> Brake Linings & Springs -> Parking Brake Cable -> Wheel Cylinder
Vehicle: 2000 Plymouth Neon 2.0 L4 GAS
Brake Drums
Any time the brake drums are removed for brake service, the braking surface diameter should be inspected with a suitable brake drum micrometer at several points to determine if they are within the safe oversize limit stamped on the brake drum outer surface. If the braking surface diameter exceeds specifications, the drum must be replaced. If the braking surface diameter is within specifications, drums should be cleaned and inspected for cracks, scores, deep grooves, taper, out of round and heat spotting. If drums are cracked or heat spotted, they must be replaced. Scoring ...
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2000 Plymouth Neon AUTOMOBILES
DaimlerChrysler/AMC/Eagle Passenger Cars -> Fuel Filter Replacement -> 2000-05 Neon & SRT-4 -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 2000 Plymouth Neon 2.0 L4 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while it relearns its adaptive strategy.
Fuel System Pressure Relief
- Remove the fuel pump relay from the Power Distribution Center (PDC). ...
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2000 Plymouth Neon AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2000 Plymouth Neon 2.0 L4 GAS
- Remove cotter pin, nut lock, and spring washer from end of outer C/V joint stub axle.
- Loosen (but do not remove) stub axle-to-hub/ bearing retaining nut. Loosen hub nut while vehicle is on floor with brakes applied. front hub and driveshaft are splined together and retained by hub nut.
- Raise vehicle on jack stands or centered on a frame contact-type hoist.
- Remove front tire and wheel assembly from hub.
- Remove front disc brake caliper assembly to steering knuckle bolts.
- Remove disc brake caliper assembly from steering knuckle. Caliper is removed by first lifting bottom of calip...
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2000 Plymouth Neon AUTOMOBILES
Alternator, Replace
Vehicle: 2000 Plymouth Neon 2.0 L4 GAS
- Disconnect battery ground cable.
- Loosen but do not remove alternator adjustment nut.
- Raise and support vehicle with front wheels turned fully to rightside.
- Remove plastic lower splash shield.
- Disconnect alternator field circuit wiring connector. Push red locking tab to release.
- Remove B+ terminal nut and wire.
- Loosen pivot bolt, but do not remove
- Remove alternator drive belt. Alternator spill s...
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2000 Plymouth Neon AUTOMOBILES
Chrysler LLC Cars -> Check Engine Lamp -> Breeze, Cirrus, Crossfire, Neon, Prowler, Sebring Convertible, Sebring Sedan, Stratus Sedan, 300M
Vehicle: 2000 Plymouth Neon 2.0 L4 GAS
The Powertrain Control Module (PCM) monitors a variety of sensors and systems. Each time the ignition is turned On, the instrument panel Malfunction Indicator Lamp (MIL) should light for approximately 2 seconds and then go out. If the PCM senses a fault condition with a monitored circuit or if the PCM enters Limp-In mode, a Dia...
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2000 Plymouth Neon AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2000 Plymouth Neon 2.0 L4 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition inlet heater hose clamp from heater core pipe.
- Remove hose from heater core.
- Reposition heater hose clamp from heater supply tube.
- Remove inlet heater hose from heater supply tube.
- Remove hose from vehicle.
- Reverse procedure to in...
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2000 Plymouth Neon AUTOMOBILES
Serpentine Drive Belt, Replace -> A/C Compressor & Alternator Belt
Vehicle: 2000 Plymouth Neon 2.0 L4 GAS
A/C Compressor & Alternator Belt
- Loosen T-Bolt locking nut and pivot bolt to remove and install belt and/or...
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2000 Plymouth Neon AUTOMOBILES
Component location diagrams for most 2000 Plymouth Neon cars and light trucks sold in the U.S. from 1990+.
LH Body Harness Splices Diagram for 2000 Plymouth Neon 2.0 L4 GAS Components on diagram: |
Rear Body Splices Diagram for 2000 Plymouth Neon 2.0 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2000 Plymouth Neon AUTOMOBILES
OEM drawn wiring diagrams for most 2000 Plymouth Neon cars and light trucks sold in the U.S.
2000 Plymouth Neon 2.0 L4 GAS Wiring Diagram Components on diagram: |
2000 Plymouth Neon 2.0 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2000 Plymouth Neon AUTOMOBILES
OEM TSB listings for most 2000 Plymouth Neon cars and light trucks sold in the U.S. from 1985+.
Document: Repair Information for Reconnection of Rear Window Defroster Contact or Tab Vehicle: 2000 Plymouth Neon 2.0 L4 GAS Auto Systems: |
Document: Exterior Lamp Condensation and Replacement Guidelines Vehicle: 2000 Plymouth Neon 2.0 L4 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2000 Plymouth Neon AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2000 Plymouth Neon cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2000 Plymouth Neon cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2000 Plymouth Neon cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2000 Plymouth Neon cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2000 Plymouth Neon SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2000 Plymouth Neon vehicle. |
Access the Complete guide! |