Auto Parts Search
2001 Hyundai Santa FE CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Hyundai REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2001 Hyundai Santa FE car and truck
repair procedures including Hyundai engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Hyundai Santa FE automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2001 Hyundai Santa FE AUTOMOBILES
Air Bag System Precautions -> Hyundai -> Arming
Vehicle: 2001 Hyundai Santa FE 2.4 L4 GAS
- Ensure nobody is inside vehicle.
- Connect battery ground cable.
- From a safe position at sides of or below air bag modules, turn ignition On and observe SRS la...
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Hyundai Santa FE AUTOMOBILES
Disc Brakes -> Caliper Service -> Accent -> Assemble -> Disassemble -> Elantra & Tiburon -> Elantra, Sonata & Tiburon -> Front -> Installation -> Rear -> Removal -> Santa Fe -> Sonata -> XG 300 & XG 350
Vehicle: 2001 Hyundai Santa FE 2.7 V6 GAS
Front
Accent
Removal
- Remove wheel/tire assembly.
- Remove brake hose from caliper and cap brake line(s).
- Remove caliper assembly as outlined under, "Brake Pad Service."
Disassemble
- Remove sleeve, sleeve boot and pin boots, Fig. .
- Protect fingers with shop towel, then blow piston from caliper bore with compressed air.
- Remove piston boot, then pry piston seal from caliper bore using a suitable screwdriver.
Assemble
- Clean all components with suitable cleaner.
- Inspect caliper bore, piston and carrier for damage or excessive wear.
- Apply suitable rubber grease to new piston seal, then install piston s...
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2001 Hyundai Santa FE AUTOMOBILES
Hyundai -> Fuel Filter Replacement -> All Models -> Fuel System Relief -> Removal & Installation
Vehicle: 2001 Hyundai Santa FE 2.4 L4 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur.
Fuel System Relief
- Disc...
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2001 Hyundai Santa FE AUTOMOBILES
CV AXLE SHAFT, Replace -> Front -> Rear
Vehicle: 2001 Hyundai Santa FE 2.4 L4 GAS
Front
- Remove aluminum wheel cover using suitable tool.
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove wheel nuts and front wheels.
- Remove split pin and castle nut.
- Drain transaxle oil.
- On models equipped with ABS, detach wheel speed sensor cable from bracket.
- Detach brake hose cable from bracket.
- Remove two flange bolts and detach knuckle from strut.
- Separate driveshaft from axle hub by tapping lightly with plastic hammer.
- Drive off driveshaft from transaxle or transfer inner shaft using a hammer and brass bar. Always use care not to damage...
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2001 Hyundai Santa FE AUTOMOBILES
Starter, Replace
Vehicle: 2001 Hyundai Santa FE 2.4 L4 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Disconnect speedometer and shift cables.
- Disconnect starter motor electrical conn...
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2001 Hyundai Santa FE AUTOMOBILES
Cabin Air Filter Service -> Hyundai -> 2001-05 Santa Fe
Vehicle: 2001 Hyundai Santa FE 2.7 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 12 months or 12,000 miles. In dusty areas change the cabin air filter more often.
- Open the glove compartment.
- Press inward at both sides of the glove compartment, then lower the glove compartment.
- Remove the lower side instrument panel crash trim pad, Fig. .
- Remove the four glove compartment upper cover retaining screws, then the cover, Fig. .
- Remove the two glove compartment retaining bolts, then the glove compartment.
- Press on the cabin air filter cover tab, then...
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2001 Hyundai Santa FE AUTOMOBILES
Hyundai -> 4WD System Warning Lamp -> Santa Fe & Tucson
Vehicle: 2001 Hyundai Santa FE 2.4 L4 GAS
This lamp should light for a few seconds when the ignition is turned On as a bulb check. If th...
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2001 Hyundai Santa FE AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2001 Hyundai Santa FE 2.7 V6 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at coolant inlet fitting.
- Remove hose from coolant inlet fitting.
- Remove hose from vehicle.
- Reverse procedu...
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2001 Hyundai Santa FE AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2001 Hyundai Santa FE 2.7 V6 GAS
- Remove cover over tensioner.
- Rotate belt tensioner pulley bolt counterclockwis...
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2001 Hyundai Santa FE AUTOMOBILES
Component location diagrams for most 2001 Hyundai Santa FE cars and light trucks sold in the U.S. from 1990+.
 Engine Compartment Diagram for 2001 Hyundai Santa FE 2.7 V6 GASComponents on diagram: |
 Instrument Panel Diagram for 2001 Hyundai Santa FE 2.7 V6 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2001 Hyundai Santa FE AUTOMOBILES
OEM drawn wiring diagrams for most 2001 Hyundai Santa FE cars and light trucks sold in the U.S.
 2001 Hyundai Santa FE 2.4 L4 GAS Wiring DiagramComponents on diagram: |
 2001 Hyundai Santa FE 2.7 V6 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2001 Hyundai Santa FE AUTOMOBILES
OEM TSB listings for most 2001 Hyundai Santa FE cars and light trucks sold in the U.S. from 1985+.
|
Document: AUTOMATIC TRANSAXLE OIL LEAK BETWEEN TRANSAXLE AND TRANSFER CASE Vehicle: 2001 Hyundai Santa FE 2.7 V6 GAS Symptoms: |
|
Document: AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST Vehicle: 2001 Hyundai Santa FE 2.4 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2001 Hyundai Santa FE AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2001 Hyundai Santa FE cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2001 Hyundai Santa FE cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2001 Hyundai Santa FE cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2001 Hyundai Santa FE cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2001 Hyundai Santa FE SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
