Auto Parts Search
2001 Volkswagen Golf CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Volkswagen REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2001 Volkswagen Golf car and truck
repair procedures including Volkswagen engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Volkswagen Golf automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2001 Volkswagen Golf AUTOMOBILES
Import Compressor Service -> Sanden Compressor -> Compressor Clutch Service -> Except Honda -> Honda -> Inspection -> Replacement
Vehicle: 2001 Volkswagen Golf 1.8 L4 GAS
Inspection
- Rotate compressor pulley by hand and check for excess bearing play and drag. Replace pulley as required.
- Apply 8 volts to the field coil and check that the armature is drawn by the rotor pulley.
- Measure clearance between pulley and armature. If the clearance is not .013-.026 inch for Honda models or .016-.031 for other models, the armature should be removed and correct number of shims should be installed.
Replacement
Honda
- Install suitable armature holder on armature with three lugs on the holder aligne...
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2001 Volkswagen Golf AUTOMOBILES
Power Brake Units -> Power Brake Unit Service -> Brake Booster Inspection -> Brake Booster, Replace
Vehicle: 2001 Volkswagen Golf GTI 2.8 V6 GAS
Brake Booster, Replace
- Remove master cylinder as outlined in this section.
- Disconnect vacuum line(s) from booster.
- Remove brake booster attaching bolts.
- Disconnect booster pushrod from brake pedal.
- Reverse pro...
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2001 Volkswagen Golf AUTOMOBILES
Volkswagen -> Fuel Filter Replacement -> Gasoline Engines -> Models w/Fitting Or Union Bolt Connection -> Models w/Fuel Hose Connection
Vehicle: 2001 Volkswagen Golf 1.8 L4 GAS
Models w/Fuel Hose Connection
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
After the battery has been disconnected and reconnected, some abnormal driveabilty symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strategy.
- Obtain the vehicle owners radio theft protection code prior to disconnecting the battery ground cable.
- Disconnect the battery ground cable.
- On models equipped with underbody moun...
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2001 Volkswagen Golf AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2001 Volkswagen Golf 1.9 L4 DIESEL
- Remove drive axle retaining nut while vehicle is still on ground.
- Raise and support vehicle, then remove tire and wheel.
- Mark position of bolts attaching ball joints to control arms, then remove bolts and separate ball joint from control arm. Discard bolts.
- Remove drive axle to transaxle drive flange attaching bolts.
- Mount a suitable puller tool onto hub assembly and press axle shaft out of hub. Do not flex CV or tripod joints more than 25° from their original angles.
- On models equipped with automatic transaxle,remove pendulum support mounting bolts, Fig. .
- Push engine and tran...
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2001 Volkswagen Golf AUTOMOBILES
Starter, Replace
Vehicle: 2001 Volkswagen Golf GTI 1.8 L4 GAS
- Remove battery and battery carrier.
- Disconnect electrical connector and remove from retainer.
- Disconnect terminal 50 connector.
- Remove nut and terminal 30 wire from starter.
- Remove wiring from wiring guides.
- Remove wiring guides.
- Raise and support vehicle.
- Remove middle cover of engine compartment noise insulation.
- Remove lefthand engine comp...
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2001 Volkswagen Golf AUTOMOBILES
Cabin Air Filter Service -> Volkswagen -> 1993-2004 Golf, GTI & Jetta
Vehicle: 2001 Volkswagen Golf 1.8 L4 GAS
On 1993-96 models, the cabin air filter should be replaced every 15,000 miles.
On 1997-2003 models, the cabin air filter should be replaced every 10,000 miles.
On 2004 models, the cabin air filter should be replaced every 24 months or 20,000 miles.
- Open the hood.
- Remove the righthand plenum cover fasteners, then the cover.
- Remove the air deflector, if equipped.
- Press the cabin air filter housing clips downward, then remove the cabin air ...
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2001 Volkswagen Golf AUTOMOBILES
Volkswagen -> Anti-Lock Brake System (ABS) Warning Lamp ->
Vehicle: 2001 Volkswagen Golf 1.9 L4 DIESEL
The anti-lock warning lamp is used to warn of an ABS fault. The lamp input monitors the condition of the system. The lamp will be lit during engine start-up, but should go out when the self-diag...
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2001 Volkswagen Golf AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2001 Volkswagen Golf 1.9 L4 DIESEL
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2001 Volkswagen Golf AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2001 Volkswagen Golf 1.8 L4 GAS
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2001 Volkswagen Golf AUTOMOBILES
Component location diagrams for most 2001 Volkswagen Golf cars and light trucks sold in the U.S. from 1990+.
 10 Pin Connector Diagram for 2001 Volkswagen Golf GTI 2.8 V6 GASComponents on diagram: |
 Rear Side Airbag Crash Sensor Diagram for 2001 Volkswagen Golf GTI 1.8 L4 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2001 Volkswagen Golf AUTOMOBILES
OEM drawn wiring diagrams for most 2001 Volkswagen Golf cars and light trucks sold in the U.S.
 2001 Volkswagen Golf 1.8 L4 GAS Wiring DiagramComponents on diagram: |
 2001 Volkswagen Golf 1.9 L4 DIESEL Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2001 Volkswagen Golf AUTOMOBILES
OEM TSB listings for most 2001 Volkswagen Golf cars and light trucks sold in the U.S. from 1985+.
|
Document: Radio, Entering and Retrieving Anti-Theft (SAFE) Code Vehicle: 2001 Volkswagen Golf 1.9 L4 DIESEL Auto Systems: |
|
Document: Oil Consumption Measurement Vehicle: 2001 Volkswagen Golf 1.9 L4 DIESEL Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2001 Volkswagen Golf AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2001 Volkswagen Golf cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2001 Volkswagen Golf cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2001 Volkswagen Golf cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2001 Volkswagen Golf cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2001 Volkswagen Golf SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
