Auto Parts Search
2002 Chevrolet Venture CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2002 Chevrolet Venture AUTOMOBILES
Component Replacement & Adjustment -> Light Duty Trucks & Vans -> Heater Core, Replace -> Astro & Safari -> Aztek & Rendezvous -> Bravada, S & T Series -> C & K Series -> Front -> G Series -> Montana, Silhouette & Venture -> Rear -> Tracker -> Vue
Vehicle: 2002 Chevrolet Venture 3.4 V6 GAS
Astro & Safari
Front
- Drain cooling system into suitable container.
- Remove heater hoses.
- Remove screws that retain cover to heater case assembly.
- Remove straps that retain heater core to heater case assembly.
- Remove heater core from vehicle.
- Reverse procedure to install.
Rear
- Recover refrigerant as outlined under .
- Remove body side front lower trim panel.
- Remove clamps from auxiliary heater pipes.
- Disconnect auxiliary heater pipes from auxiliary heater module.
- Remove screws and ban...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Chevrolet Venture AUTOMOBILES
Drum Brakes -> Adjustments -> Astro, Bravada, S & T Series & Safari -> Automatic Apply Parking Brakes -> Aztek, Montana, Rendezvous, Silhouette, Trans Sport, Vue & Venture -> C & K Series -> Control Rod -> Express, Savana & P Series -> Lever Type -> Manual Parking Brake -> Optional Method -> Pedal Type -> Propeller Shaft Type -> Service Brake -> Standard Method -> Tracker
Vehicle: 2002 Chevrolet Venture 3.4 V6 GAS
Service Brake
These brakes have self-adjusting shoe mechanisms that ensure correct lining-to-drum clearances at all times. The automatic adjusters operate only when the brakes are applied as the vehicle is moving rearward or when the vehicle comes to an uphill stop.
Although the brakes are self-adjusting, an initial adjustment is required after the brake shoes have been relined or replaced, or when the length of the adjusting screw has been changed during some other service operation.
Frequent usage of an automatic transmission forward range to halt reverse vehicle motion may prevent t...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2002 Chevrolet Venture AUTOMOBILES
General Motors Corp./Saturn Light Trucks, SUVs & Vans -> Component Locations -> 1997-06 Rendezvous, Aztek, Montana w/3.4L Engine, C SRX, Venture, Silhouette, Trans Sport & Vue
Vehicle: 2002 Chevrolet Venture 3.4 V6 GAS
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2002 Chevrolet Venture AUTOMOBILES
CV AXLE SHAFT, Replace -> Front -> Rear
Vehicle: 2002 Chevrolet Venture 3.4 V6 GAS
Front
- Raise and support vehicle.
- Remove tire and wheel assembly.
- Remove engine splash shield.
- Insert a drift or punch through brake caliper and into brake rotor in order to prevent wheel hub and bearing from turning.
- Remove wheel drive shaft spindle nut.
- Remove stabilizer shaft link.
- Disconnect outer tie rod end from steering knuckle. Do not loosen tie rod end jam nut.
- Disconnect electrical connector from wheel speed sensor and reposition wiring harness away from ball joint.
- Disconnect lower ball joint from steering knuckle.
- Install wheel hub remover tool No. J42129 or equivalent o...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2002 Chevrolet Venture AUTOMOBILES
Starter, Replace
Vehicle: 2002 Chevrolet Venture 3.4 V6 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Disconnect starter electrical connectors.
- Remove converter cover.
- Remove mountin...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2002 Chevrolet Venture AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1998-2005 Montana, Silhouette, Trans Sport, Venture & 2002-03 Rendezvous
Vehicle: 2002 Chevrolet Venture 3.4 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Open the instrument panel compartment door.
- Remove the door located at the rear of the instrument panel compartment.
- Open the A/C and heater module access door, Fig. .
- Remove the first cabin air filter through the A/C and heater module access...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2002 Chevrolet Venture AUTOMOBILES
General Motors Corp./Saturn Trucks -> Anti-Lock Brake System Warning Lamp ->
Vehicle: 2002 Chevrolet Venture 3.4 V6 GAS
This lamp should light for approximately 6-8 seconds when the ignition is turned On as a bulb check. If the warn...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2002 Chevrolet Venture AUTOMOBILES
Radiator, Replace
Vehicle: 2002 Chevrolet Venture 3.4 V6 GAS
- Drain engine coolant into a suitable container.
- Disconnect lower transmission oil cooler (TOC) line from radiator.
- Remove cooling fans and shroud.
- Remove radiator inlet hose.
- Remove ra...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2002 Chevrolet Venture AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2002 Chevrolet Venture 3.4 V6 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2002 Chevrolet Venture AUTOMOBILES
Component location diagrams for most 2002 Chevrolet Venture cars and light trucks sold in the U.S. from 1990+.
Steering Wheel Diagram for 2002 Chevrolet Venture 3.4 V6 GAS Components on diagram: |
Starter Solenoid,Transmission Range Switch,A/C Compressor and CKPA Connector Diagram for 2002 Chevrolet Venture 3.4 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2002 Chevrolet Venture AUTOMOBILES
OEM drawn wiring diagrams for most 2002 Chevrolet Venture cars and light trucks sold in the U.S.
2002 Chevrolet Venture 3.4 V6 GAS Wiring Diagram Components on diagram: |
2002 Chevrolet Venture 3.4 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2002 Chevrolet Venture AUTOMOBILES
OEM TSB listings for most 2002 Chevrolet Venture cars and light trucks sold in the U.S. from 1985+.
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2002 Chevrolet Venture 3.4 V6 GAS Auto Systems: |
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2002 Chevrolet Venture 3.4 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2002 Chevrolet Venture AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2002 Chevrolet Venture cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2002 Chevrolet Venture cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2002 Chevrolet Venture cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2002 Chevrolet Venture cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Venture SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2002 Chevrolet Venture vehicle. |
Access the Complete guide! |