Auto Parts Search
2002 Jaguar XJ8 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Jaguar REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
A/C & HEATER SERVICE PROCEDURES FOR 2002 Jaguar XJ8 AUTOMOBILES
Electrical Symbol & Wire Color Code Identification -> Wire Color Code Identification -> Imported Vehicles
Vehicle: 2002 Jaguar XJ8 4.0 V8 GAS
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Jaguar XJ8 AUTOMOBILES
Anti-lock Brakes -> System Service -> ABS/Traction Control Module (ABS/TCM) -> Brake System Bleed -> Component Replacement -> Fluid Intake Hose -> Front -> Hydraulic Control Unit (HCU) -> Lateral Acceleration & Rotation Sensors -> Rear -> S-Type -> Steering Wheel Rotation Sensor -> Wheel Speed Sensor -> X-Type -> XKR & XK8 -> Yaw Rate Sensor
Vehicle: 2002 Jaguar XJ8 4.0 V8 GAS
Brake System Bleed
Bleeding the ABS system is not a routine maintenance operation and is only required when part of the system has been disconnected or the fluid is contaminated.
During the bleeding procedure, it is important that the level of fluid in the reservoir is maintained at approximately .0787 inch below the bottom of the filler neck. Motor/pump unit cannot charge accumulator if air and not fluid, is standing on low pressure side of pump.
If motor/pump unit, fluid intake hose or hydraulic unit of ABS system has been removed or disconnected, bleed as outlined in "Fluid Intake... "
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2002 Jaguar XJ8 AUTOMOBILES
Jaguar -> Fuel Filter Replacement -> XJ8, XJR, XK8 & XJR -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 2002 Jaguar XJ8 4.0 V8 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the vehicle relearns its adaptive strategy.
Fuel System Pressure Relief
- Disconnect the battery ground cable.
- Remove the lefthand engin...
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2002 Jaguar XJ8 AUTOMOBILES
CV AXLE SHAFT, Replace -> REAR
Vehicle: 2002 Jaguar XJ8 4.0 V8 GAS
REAR
- Raise and support vehicle, then remove tire and wheel assemblies.
- Remove rear suspension assembly.
- Compress rear spring with a suitable spring compressor tool and mark tool position on spring.
- Remove lower mounting nut and bolt, then the shock absorber.
- Repeat previous steps to remove other shock absorber.
- Disconnect in-line connector, then remove out frame clips and clear parking brake cable through frame.
- Remove mounting nut and lower fulcrum shaft.
- Remove axle shaft drive flange nuts.
- Support axle shaft assembly, then remove hub fulcrum. Mark and remove camber adjustment s...
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2002 Jaguar XJ8 AUTOMOBILES
Alternator, Replace
Vehicle: 2002 Jaguar XJ8 4.0 V8 GAS
- Remove air cleaner assembly.
- Remove twin fan and motor assembly from behind radiator.
- On models equipped with supercharger, remove supercharger drive belt and belt tensioner.
- On all models, remove serpentine drive belt.
- Raise and support vehicle.
- Remove air intake duct from alternator.
- Disconnect alternator harness from alternator.
- Remove lower mounting bolt and position harness mounting bracket aside.
- On mod...
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2002 Jaguar XJ8 AUTOMOBILES
Cabin Air Filter Service -> Jaguar -> 1998-2003 XJ8
Vehicle: 2002 Jaguar XJ8 4.0 V8 GAS
Under normal operating conditions the cabin air filter should be replaced every 20,000 miles. In dusty areas change the cabin air filter more often.
- Open the hood.
- Note position of the windshield wiper blades on the windshield.
- Disconnect the windshield washer hose from the plenum cover connector.
- Remove the windshield wiper arm nut covers.
- Loosen the windshield wiper arm retaining nuts.
- Release the wiper arm from the spindle using a suitable windshield arm puller.
- Remove the wiper arm retaining nut, then the wiper arm.
- Remove the plenum cover screw covers.
- Remove the plenum cover screws a...
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2002 Jaguar XJ8 AUTOMOBILES
Jaguar -> Air Bag Warning Lamp ->
Vehicle: 2002 Jaguar XJ8 4.0 V8 GAS
If the Air Bag warning lamp lights and stays on, diagnosis and ...
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2002 Jaguar XJ8 AUTOMOBILES
Coolant Hose, Replace -> Lower -> Non-supercharged -> Supercharged -> Upper
Vehicle: 2002 Jaguar XJ8 4.0 V8 GAS
Supercharged
Lower
- Drain coolant into a suitable container.
- Remove two screws which secure radiator grille and remove grille for access.
- Release and reposition spring clip, and disconnect hose from charge air cooler radiator.
- Slacken hose retaining clip and reposition clip along hose.
- Disconnect hose from radiator.
- Release and reposition hose clip, and disconnect bottom hose from thermostat cover.
- Release and reposition hose clips, and disconnect two sections of molded hose from air charge cooler.
- Remove hose assembly from vehicle.
- Reverse procedure to install.
Upper
- Drain coolant int...
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2002 Jaguar XJ8 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2002 Jaguar XJ8 4.0 V8 GAS
- Install suitable spanner wrench tool, on belt tensioner pulley center bolt.
- Turn tool counterclo...
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2002 Jaguar XJ8 AUTOMOBILES
Component location diagrams for most 2002 Jaguar XJ8 cars and light trucks sold in the U.S. from 1990+.
Wiring Harnesses Diagram for 2002 Jaguar XJ8 4.0 V8 GAS Components on diagram: |
Latch Plate Location Diagram for 2002 Jaguar XJ8 4.0 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2002 Jaguar XJ8 AUTOMOBILES
OEM drawn wiring diagrams for most 2002 Jaguar XJ8 cars and light trucks sold in the U.S.
2002 Jaguar XJ8 4.0 V8 GAS Wiring Diagram Components on diagram: |
2002 Jaguar XJ8 4.0 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2002 Jaguar XJ8 AUTOMOBILES
OEM TSB listings for most 2002 Jaguar XJ8 cars and light trucks sold in the U.S. from 1985+.
Document: UNABLE TO LOCK VEHICLE WITH REMOTE KEY FOB - REPAIR PROCEDURE Vehicle: 2002 Jaguar XJ8 4.0 V8 GAS Symptoms: |
Document: SERVICE ACTION: FUEL FILLER CAP DIFFICULT TO INSTALL / CHECK ENGINE MIL ON - REVISED FUEL FILLER CAP - REVISED Vehicle: 2002 Jaguar XJ8 4.0 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2002 Jaguar XJ8 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2002 Jaguar XJ8 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2002 Jaguar XJ8 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2002 Jaguar XJ8 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2002 Jaguar XJ8 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2002 Jaguar XJ8 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2002 Jaguar XJ8 vehicle. |
Access the Complete guide! |