Auto Parts Search
BRAKE SERVICE PROCEDURES FOR 2003 Jaguar XKR AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2003 Jaguar XKR cars and light trucks from 1990+.
Anti-lock Brakes -> Troubleshooting
Vehicle: 2003 Jaguar XKR 4.2 V8 GAS
Refer to F...
CLICK HERE TO GET FULL ACCESS TO 2003 Jaguar XKR BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2003 Jaguar XKR AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2003 Jaguar XKR cars and light trucks from 1990+.
Power Brake Units -> Power Brake Unit Service -> Replacement -> S-Type & X-Type -> XKR & XK8
Vehicle: 2003 Jaguar XKR 4.2 V8 GAS
Replacement
S-Type & X-Type
- Remove wiper arms.
- Remove cowl grille and engine compartment brace.
- Remove master cylinder as outlined in "Hydraulic Brake Systems" section.
- Remove expansion tank.
- Remove mounting screws and disconnect clips, then remove driver's side instrument panel lower panel.
- Disconnect fuel flap and luggage compartment release switch electrical connector.
- Remove mounting screws and driver's side air duct.
- Disconnect hood latch release handle supporting plate.
- Remove clip and brake booster retaining pin.
- Remove mounting nuts and brake booster with non-return valve/va...
CLICK HERE TO GET FULL ACCESS TO 2003 Jaguar XKR BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2003 Jaguar XKR AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2003 Jaguar XKR cars and light trucks from 1990+.
Hydraulic Brake Systems -> Component Replacement -> Master Cylinder
Vehicle: 2003 Jaguar XKR 4.2 V8 GAS
Master Cylinder
- Remove brake fluid reservoir cap cover and disconnect brake fluid level indicator wires.
- Remove reservoir cap and filter.
- Drain fluid from master cylinder using suitable syringe.
- Disconnect and plug master cylinder brake lines.
- Oper...
CLICK HERE TO GET FULL ACCESS TO 2003 Jaguar XKR BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2003 Jaguar XKR AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2003 Jaguar XKR cars and light trucks from 1990+.
Disc Brakes -> Precautions -> Battery Ground Cable -> Relieving Line Pressure
Vehicle: 2003 Jaguar XKR 4.2 V8 GAS
Relieving Line Pressure
Discharge hydraulic accumulator by depressing brake pedal until pedal becomes difficult to o...
CLICK HERE TO GET FULL ACCESS TO 2003 Jaguar XKR BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2003 Jaguar XKR AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2003 Jaguar XKR cars and light trucks from 1990+.
Anti-lock Brakes -> System Service -> ABS/Traction Control Module (ABS/TCM) -> Brake System Bleed -> Component Replacement -> Fluid Intake Hose -> Front -> Hydraulic Control Unit (HCU) -> Lateral Acceleration & Rotation Sensors -> Rear -> S-Type -> Steering Wheel Rotation Sensor -> Wheel Speed Sensor -> X-Type -> XKR & XK8 -> Yaw Rate Sensor
Vehicle: 2003 Jaguar XKR 4.2 V8 GAS
Brake System Bleed
Bleeding the ABS system is not a routine maintenance operation and is only required when part of the system has been disconnected or the fluid is contaminated.
During the bleeding procedure, it is important that the level of fluid in the reservoir is maintained at approximately .0787 inch below the bottom of the filler neck. Motor/pump unit cannot charge accumulator if air and not fluid, is standing on low pressure side of pump.
If motor/pump unit, fluid intake hose or hydraulic unit of ABS system has been removed or disconnected, bleed as outlined in "Fluid Intake... "
CLICK HERE TO GET FULL ACCESS TO 2003 Jaguar XKR BRAKE SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2003 Jaguar XKR AUTOMOBILES
Includes anti-lock brakes, disc, drum, power and hydraulic brake services diagnostics and procedures for domestic and imported 2003 Jaguar XKR cars and light trucks from 1990+.
Disc Brakes -> Brake System Bleed
Vehicle: 2003 Jaguar XKR 4.2 V8 GAS
Refer t...
CLICK HERE TO GET FULL ACCESS TO 2003 Jaguar XKR BRAKE SERVICE PROCEDURES
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2003 Jaguar XKR vehicle. |
Access the Complete guide! |