Auto Parts Search
2005 Scion TC CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Scion REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2005 Scion TC car and truck
repair procedures including Scion engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Scion TC automobile. Try the Automotix DIY solution today!
BRAKE SERVICE PROCEDURES FOR 2005 Scion TC AUTOMOBILES
Scion -> Power Brake Units -> Adjustments -> Brake Pedal Height & Freeplay
Vehicle: 2005 Scion TC 2.4 L4 GAS
Brake Pedal Height & Freeplay
Refer to Fig. for pedal height and freeplay specifications.
- Remove lower instrument finish panel.
- Disconnect stop lamp switch electrical connector.
- Loosen stop lamp switch lock nut, then remove stop lamp switch.
- Loosen brake master cylinder push rod clevis lock nut.
- Adjust pedal height by turning pedal push rod.
- Torque push rod lock nut to 19 ft. lbs.
- Install stop lam...
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2005 Scion TC AUTOMOBILES
Scion -> Fuel Filter Replacement -> tC -> Fuel System Pressure Relief -> Removal & Installation
Vehicle: 2005 Scion TC 2.4 L4 GAS
Fuel System Pressure Relief
- Disconnect and isolate battery negative terminal.
- Remove rear seat cushion by pulling up on two front hooks, then releasing hooks from seat back frame.
- Remove fuel pump module service hole cover.
- Disconnect fuel pump electrical connector.
- Connect battery and start engine.
- Allow engine to idle until it stalls, then attempt to restart engine. DTC P0171 system lean may be set.
- Remove fuel tank cap to release pressure in fuel tank.
- Disconnect and isolate battery negative terminal.
- Connect fuel pump electrical connector.
- Install service hole cover, then the rear seat cushion.
Rem...
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2005 Scion TC AUTOMOBILES
CV AXLE SHAFT, Replace -> Front -> Rear
Vehicle: 2005 Scion TC 2.4 L4 GAS
Front
Before removing front axle assembly, remove wheel sensor from assembly. Move it away from front axle assembly area. Failure to follow these instructions may result in damage to sensor wires and wheel sensor becoming inoperative.
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove drain plug and drain transaxle fluid into suitable container.
- Remove wheel nuts and front wheels.
- Remove engine undercover bolts, then remove cover.
- Loosen staked part of wheel hub locknut completely to avoid damage to hub shaft.
- Apply brake pedal and remove hub...
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2005 Scion TC AUTOMOBILES
Component Replacement -> Installation -> Removal -> Reset Switch
Vehicle: 2005 Scion TC 2.4 L4 GAS
Reset Switch
Removal
- Disconnect the battery ground cable.
- Remove the glove compartment door assembly, Fig. .
- Remove the reset switch by disengaging the two retaining claws, then disconnect the electrical connector and remove the switch.
...
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2005 Scion TC AUTOMOBILES
Starter, Replace
Vehicle: 2005 Scion TC 2.4 L4 GAS
- Disconnect battery ground cable.
- Disconnect starter electrical connector.
- Open terminal cap, remove nut and starter wire.
- Remove starter...
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2005 Scion TC AUTOMOBILES
Cabin Air Filter Service -> Scion -> 2005-09 tC
Vehicle: 2005 Scion TC 2.4 L4 GAS
The cabin air filter should be replaced every 36 months or 30,000 miles.
- Open the glove compartment, then detach the damper rod, Fig. .
- Push inward on each side of the glove compartment to disengage the stops, then lower and remove the glove compartment, Fig. .
- Disengage the two cabin air filter cover to housing retai...
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2005 Scion TC AUTOMOBILES
Scion -> Air Bag Warning Lamp ->
Vehicle: 2005 Scion TC 2.4 L4 GAS
- Connect two service wires to terminals Tc and CG of DLC3 (Data Link Connector), then place ignition switch in on position, Fig. .
- Disconnect Tc within 3-10 seconds after DTC output begins.
- Supplemental Restraint System (SRS) warning lamps will illuminate three seconds later. Within 2-4 seconds, connect terminals Tc and CG of DLC3.
- SRS warning lamp will go off within 2-4 secon...
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2005 Scion TC AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2005 Scion TC 2.4 L4 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at water inlet.
- Remove hose from water inlet.
- Remove hose from vehicle.
- Reverse procedure t...
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2005 Scion TC AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2005 Scion TC 2.4 L4 GAS
- Rotate or lift the belt tensioner arm, using a suitable tool to relieve tension from dr...
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2005 Scion TC AUTOMOBILES
Component location diagrams for most 2005 Scion TC cars and light trucks sold in the U.S. from 1990+.
 Splice Points Locations Diagram for 2005 Scion TC 2.4 L4 GASComponents on diagram: |
 Engine Compartment Component Locations Diagram for 2005 Scion TC 2.4 L4 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2005 Scion TC AUTOMOBILES
OEM drawn wiring diagrams for most 2005 Scion TC cars and light trucks sold in the U.S.
 2005 Scion TC 2.4 L4 GAS Wiring DiagramComponents on diagram: |
 2005 Scion TC 2.4 L4 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2005 Scion TC AUTOMOBILES
OEM TSB listings for most 2005 Scion TC cars and light trucks sold in the U.S. from 1985+.
|
Document: DRIVER'S SEATBACK LOCK RELEASE LEVER INOPERATIVE Vehicle: 2005 Scion TC 2.4 L4 GAS Auto Systems: |
|
Document: IG1 Relay Freezing Vehicle: 2005 Scion TC 2.4 L4 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2005 Scion TC AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2005 Scion TC cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2005 Scion TC cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2005 Scion TC cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2005 Scion TC cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2005 Scion TC SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
