Auto Parts Search
2006 Suzuki Aerio CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Suzuki REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
FUEL FILTER REPLACEMENT PROCEDURES FOR 2006 Suzuki Aerio AUTOMOBILES
Suzuki -> Component Locations -> Aerio -> Equipped w/Onboard Refueling Vapor Recovery System
Vehicle: 2006 Suzuki Aerio 2.3 L4 GAS
Equipped w/Onboard Refueling Vapor Recovery Syste...
CLICK HERE TO GET FULL ACCESS TO 2006 Suzuki Aerio FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2006 Suzuki Aerio AUTOMOBILES
CV AXLE SHAFT, Replace -> Front -> Rear
Vehicle: 2006 Suzuki Aerio 2.3 L4 GAS
Front
- Undo staking and remove drive shaft nut and washer.
- Raise and support vehicle.
- Remove wheel.
- Drain transaxle oil.
- Remove tie rod end split pin and castle nut.
- Disconnect tie rod end from steering knuckle by using special tool 09913-65210 or equivalent.
- Using plastic hammer, drive out drive shaft joint so as to release snap ring fitting of joint spline at center shaft.
- Disconnect front suspension control arm ball stud from steering knuckle after removing ball stud bolt and nut.
- Remove drive shaft assembly. To prevent damage of boots, be careful not to contact them with other ...
CLICK HERE TO GET FULL ACCESS TO 2006 Suzuki Aerio DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2006 Suzuki Aerio AUTOMOBILES
Alternator, Replace
Vehicle: 2006 Suzuki Aerio SX 2.3 L4 GAS
- Disconnect battery ground cable.
- Remove air cleaner hose intake clamps, disconnect MAP sensor connector, and remove bolts securing housing assembly.
- Remove power steering return pipe clamp bolt.
- Remove righthand front drive shaft nut and washer.
- Raise vehicle on suitable lift.
- Remove righthand side front wheel nuts then remove wheel.
- Remove transaxle drain plug and drain oil into clean container.
- Remove cotter pin and castle nut from tie rod end.
- Separate tie rod end from steering knuckle by using suitable tool.
- Tap with plastic hammer and drive out shaft joint to release snap ring f...
CLICK HERE TO GET FULL ACCESS TO 2006 Suzuki Aerio STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2006 Suzuki Aerio AUTOMOBILES
Suzuki -> Anti-Lock Brake System Warning Lamp -> 2002-07 Aerio
Vehicle: 2006 Suzuki Aerio SX 2.3 L4 GAS
The Anti-Lock Brake System (ABS) indicator lamp should illuminate for approximately 2 seconds as a bulb check when the ignition Switch is placed in the on position. If the lamp remains illuminated or comes on while driving the vehicle or is blinking, a fault in the ABS has been detected. After diagnosis and repair are completed, the DTCs can be cleared using a suitable scan tool or as follows:
- Place ignition switch in the off position.
- Co...
CLICK HERE TO GET FULL ACCESS TO 2006 Suzuki Aerio MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2006 Suzuki Aerio AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2006 Suzuki Aerio Premium 2.3 L4 GAS
Inlet
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at heater core.
- Remove hose from heater core.
- Reposition hose clamp at water outlet on cylinder head.
- Remove hose from water outlet.
- Remove hose from vehicle.
- Reverse procedu...
CLICK HERE TO GET FULL ACCESS TO 2006 Suzuki Aerio RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2006 Suzuki Aerio AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2006 Suzuki Aerio SX 2.3 L4 GAS
- Remove battery ground cable.
- Remove nuts from righthand engine cover, then remove cover.
- Rotate or lift belt tensioner arm clockwise, using...
CLICK HERE TO GET FULL ACCESS TO 2006 Suzuki Aerio SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2006 Suzuki Aerio AUTOMOBILES
Component location diagrams for most 2006 Suzuki Aerio cars and light trucks sold in the U.S. from 1990+.
Airbag Components Diagram for 2006 Suzuki Aerio SX Premium 2.3 L4 GAS Components on diagram: |
Suspension Components Diagram for 2006 Suzuki Aerio Premium 2.3 L4 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Suzuki Aerio PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2006 Suzuki Aerio AUTOMOBILES
OEM drawn wiring diagrams for most 2006 Suzuki Aerio cars and light trucks sold in the U.S.
2006 Suzuki Aerio Premium 2.3 L4 GAS Wiring Diagram Components on diagram: |
2006 Suzuki Aerio SX Premium 2.3 L4 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2006 Suzuki Aerio WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2006 Suzuki Aerio AUTOMOBILES
OEM TSB listings for most 2006 Suzuki Aerio cars and light trucks sold in the U.S. from 1985+.
Document: CORRECT COOLANT USAGE Vehicle: 2006 Suzuki Aerio 2.3 L4 GAS Auto Systems: |
Document: TIRE PRESSURE MONITORING SYSTEM (TPMS) DIAGNOSTIC TIPS Vehicle: 2006 Suzuki Aerio 2.3 L4 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2006 Suzuki Aerio TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2006 Suzuki Aerio AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2006 Suzuki Aerio cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2006 Suzuki Aerio cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2006 Suzuki Aerio cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2006 Suzuki Aerio cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2006 Suzuki Aerio SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2006 Suzuki Aerio vehicle. |
Access the Complete guide! |