Auto Parts Search
2007 Toyota Tundra CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Toyota REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Toyota Tundra AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2007 Toyota Tundra 5.7 V8 GAS
- Raise and support vehicle and support it with safety stands in proper locations.
- Remove wheel nuts and front wheels.
- Remove engine undercover retainer, then remove undercover.
- Disconnect front ABS speed sensor.
- On models equipped with 4WD, drain differential oil into suitable container.
- On all models, remove hub cap and cotter pin.
- Apply brakes and remove lefthand driveline hub nut.
- Remove tie rod end nut.
- Remove bolt and nuts and separate lefthand front suspension arm subassembly from lower ball joint.
- Disengage driveshaft from axle hub using plastic hammer.
- Push steering k...
CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tundra DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Toyota Tundra AUTOMOBILES
Reset Procedures
Vehicle: 2007 Toyota Tundra SR5 4.7 V8 GAS
This warning lamp will illuminate when tire pressure falls below a specified psi. When the warning lamp illuminates, check the air...
CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tundra TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Toyota Tundra AUTOMOBILES
Starter, Replace
Vehicle: 2007 Toyota Tundra 4.7 V8 GAS
- Disconnect battery ground cable. After removing battery ground cable wait 90 seconds to prevent air bag and seat belt pretensioner activation.
- Remove air pump assembly.
- Remove nut from righthand and lefthand wiper arm blade assembly.
- Release tabs from righthand and lefthand fender cowl seal.
- Remove clips securing righthand and lefthand cowl top ventilator louver subassembly.
- Disconnect electrical connector from wiper motor.
- Remove nut securing wiper motor arm link to wiper motor. Insert a suitable tool underneath wiper motor pivot arm and pry carefully upward to separate wiper link f...
CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tundra STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2007 Toyota Tundra AUTOMOBILES
Cabin Air Filter Service -> Toyota -> Tundra
Vehicle: 2007 Toyota Tundra SR5 4.0 V6 GAS
The cabin air filter should be cleaned every 18 months or 15,000 miles and replaced every 36 months or 30,000 miles. The filter should be replaced more often if air flow is less than normal.
- Open the glove compartment door.
- Slide off the glove damper rod, Fig. .
- Push inward on each side of the glove compartment door to disengage claws, Fig. .
- Remove the cabin air filter c...
CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tundra CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Toyota Tundra AUTOMOBILES
Toyota -> Air Bag Warning Lamp -> 2005-09 Tundra
Vehicle: 2007 Toyota Tundra 5.7 V8 GAS
- Connect two service wires to terminals Tc and CG of data link connector.
- Turn ignition switch to On position and wait for approximately 6 seconds.
- SRS warning lamps will illuminate 2-4 seconds later. Within 1-5 seconds, ground terminal Tc of DLC.
- SRS warning lamp will go off within 2-4 seconds. Within 1-5 seconds, release...
CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tundra MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Toyota Tundra AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2007 Toyota Tundra Limited 5.7 V8 GAS
Inlet
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at heater core.
- Remove hose from heater core.
- Reposition hose clamp at water outlet.
- Remove hose from water outlet.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp a...
CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tundra RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Toyota Tundra AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Toyota Tundra 5.7 V8 GAS
- Remove nuts from V-Bank engine cover subassembly, then remove cover.
- Remove air cleaner hose assembly by loosing clamps, then remove hose assembly.
- Remove bolts from engine under cover subassembly, then remove engine cover.
- Rotate or ...
CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tundra SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Toyota Tundra AUTOMOBILES
Component location diagrams for most 2007 Toyota Tundra cars and light trucks sold in the U.S. from 1990+.
Front Body Components Diagram for 2007 Toyota Tundra SR5 4.0 V6 GAS Components on diagram: |
Shift Control System Diagram for 2007 Toyota Tundra Limited 4.7 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tundra PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Toyota Tundra AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Toyota Tundra cars and light trucks sold in the U.S.
2007 Toyota Tundra 5.7 V8 GAS Wiring Diagram Components on diagram: |
2007 Toyota Tundra SR5 4.0 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tundra WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Toyota Tundra AUTOMOBILES
OEM TSB listings for most 2007 Toyota Tundra cars and light trucks sold in the U.S. from 1985+.
Document: Grinding Noise When in 4WD Vehicle: 2007 Toyota Tundra 4.7 V8 GAS Symptoms: |
Document: ECM CALIBRATION: TRD SUPERCHARGED 3UR-FE DRIVEABILITY Vehicle: 2007 Toyota Tundra 5.7 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tundra TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Toyota Tundra AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Toyota Tundra cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Toyota Tundra cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Toyota Tundra cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Toyota Tundra cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Toyota Tundra SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Toyota Tundra vehicle. |
Access the Complete guide! |