Auto Parts Search
2009 Scion XD CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Scion REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Scion XD AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2009 Scion XD 1.8 L4 GAS
- Raise and support vehicle.
- Remove engine under cover.
- Drain transmission fluid into a suitable container.
- Remove wheel lug nuts.
- Remove front axle hub nut.
- Remove bolt and separate speed sensor and flexible hose.
- Remove nut and separate stabilizer link from shock absorber.
- Remove cotter pin and castle nut from tie rod.
- Make sure upper ends of threaded section of tie rod end and SST (spacer B) are aligned.
- Separate tie rod end from front axle assembly.
- Remove clip and castle nut from lower control arm.
- Separate front lower contr...
CLICK HERE TO GET FULL ACCESS TO 2009 Scion XD DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Scion XD AUTOMOBILES
Component Locations
Vehicle: 2009 Scion XD 1.8 L4 GAS
Refer to F...
CLICK HERE TO GET FULL ACCESS TO 2009 Scion XD TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Scion XD AUTOMOBILES
Alternator, Replace
Vehicle: 2009 Scion XD 1.8 L4 GAS
- Disconnect cable from battery ground terminal.
- Remove righthand engine under cover.
- Remove cylinder head cover.
- Remove fan and alternator V-belt.
- Remove two bolts and remove righthand engine mounting stay.
- Place a wooden block on a jack underneath engine.
- Remove six bolts and nut and remove righthand engine mounting insulator sub-assembly. Do not remove bolt attaching insulator to stay.
- Remove three bolts and remove engine mounting bracket.
- Remove two bolts and remove fan belt adjusting bar.
- Remove terminal cap.
- Remove nut and remove terminal B+.
- Disconnect connector and harness clamp.
- ...
CLICK HERE TO GET FULL ACCESS TO 2009 Scion XD STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2009 Scion XD AUTOMOBILES
Cabin Air Filter Service -> Scion -> 2008-09 xD
Vehicle: 2009 Scion XD 1.8 L4 GAS
The cabin air filter should be replaced every 36 months or 30,000 miles.
- Open the glove compartment, then detach the damper rod, Fig. .
- Push inward on each side of the glove compartment to disengage the stops, then lower and remove the glove compartment, Fig. .
- Pinch the cabin air filter cover tabs at each side of the cover, then remove the cover, Fig. .
- Pu...
CLICK HERE TO GET FULL ACCESS TO 2009 Scion XD CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2009 Scion XD AUTOMOBILES
Scion -> Engine Oil Reminder Lamp -> 2008-09 xD
Vehicle: 2009 Scion XD 1.8 L4 GAS
The Maintenance Required reminder lamp will light as a bulb check feature when the ignition is first turned On, then go out after a few seconds. After 5000 miles have elapsed it will light for approximately three seconds after ignition turn-on, then flash for 12 seconds. If the elapsed mileage exceeds 7500 miles, the lamp will light at ignition turn-on and stay lit.
To reset reminder lamp, proceed as follows:
- Place the ignition switch in the on position.
- Ensure odometer is set to...
CLICK HERE TO GET FULL ACCESS TO 2009 Scion XD MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Scion XD AUTOMOBILES
Coolant Hose, Replace -> Lower -> Upper
Vehicle: 2009 Scion XD 1.8 L4 GAS
Lower
- Disconnect battery ground cable.
- Drain cooling system into a suitable container by loosening drain plug of radiator.
- Reposition hose clamp at radiator outlet.
- Remove hose from radiator.
- Reposition hose clamp at water inlet.
- Remove hose from water inlet.
- Remove hose from vehicle.
- Reverse procedure t...
CLICK HERE TO GET FULL ACCESS TO 2009 Scion XD RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Scion XD AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Scion XD 1.8 L4 GAS
- Remove righthand bolts from engine under cover
- Remove engine under cover.
- Remove bolts from engine head cover.
- Remove engine head cover.
- Loosen bolts from alternator mounting bracket.
- Rotate adjusting bolt counterclockwise, using a suitabl...
CLICK HERE TO GET FULL ACCESS TO 2009 Scion XD SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Scion XD AUTOMOBILES
OEM TSB listings for most 2009 Scion XD cars and light trucks sold in the U.S. from 1985+.
Document: Coolant Leak and/or Abnormal Noise from Water Pump Vehicle: 2009 Scion XD 1.8 L4 GAS Symptoms: |
Document: Brief Engine Knock/Rattle Noise at Cold Startup Vehicle: 2009 Scion XD 1.8 L4 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2009 Scion XD TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Scion XD AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Scion XD cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Scion XD cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Scion XD cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Scion XD cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Scion XD SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Scion XD vehicle. |
Access the Complete guide! |