Auto Parts Search
2002 Chevrolet Monte Carlo CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Chevrolet REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- A/C & Heater Service
- Brake Service
- Fuel Filter Replacement
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Cabin Air Filter Locations & Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
Automotix DIY provides automotive consumers and do it yourselfers; the most comprehensive repair information about 2002 Chevrolet Monte Carlo car and truck
repair procedures including Chevrolet engine diagrams, wiring diagrams, repair work estimating measures, technical service bulletins, auto body work
guidance, starter & alternator replacement procedures, serpentine belt replacement procedures, radiator & hose replacement procedures, tune-up &
drivability specifications, quick lube illustrations, preventive maintenance guide, engine light reset instructions, parts removal and install
procedures, fuel filter replacement directions, component location diagrams, air filter locations & replacement instructions, a/c
system specifications, and general auto service procedures. You don't have to be a car mechanic or technician to know how to fix
your Chevrolet Monte Carlo automobile. Try the Automotix DIY solution today!
A/C & HEATER SERVICE PROCEDURES FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
Drive Belt Data -> Domestic Passenger Cars -> 2001-02
Vehicle: 2002 Chevrolet Monte Carlo LS 3.4 V6 GAS
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo A/C & HEATER SERVICE PROCEDURES
BRAKE SERVICE PROCEDURES FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
Anti-lock Brakes -> Delphi DBC 7 -> System Service -> Alero & Grand Am -> Alero, Cavalier, Century, Grand Am, Impala, Monte Carlo, Regal & Sunbird -> Alero, Cavalier, Grand Am & Sunfire -> Automated Bleed -> BPMV Bracket -> Brake Pressure Modulator Valve (BPMV) -> Brake System Bleed -> Cavalier & Sunfire -> Century, Impala, Monte Carlo & Regal -> Component Replacement -> CTS -> Electronic Brake Control Module (EBCM) -> Front -> Hydraulic System Flush -> Malibu -> Manual Bleed -> Manual Flush -> Pressure Flush -> Rear -> Wheel Speed Sensor
Vehicle: 2002 Chevrolet Monte Carlo SS 3.8 V6 GAS
Brake System Bleed
In most circumstances a manual brake bleed is all that is required. Automated ABS bleeding is required under the following conditions: when manual bleeding does not achieve desired pedal height or feel; brake pressure modulator valve (BPMV) replacement; extreme loss of brake fluid; air ingestion is suspected.
Manual Bleed
Use suitable container to catch fluid.
- Clean reservoir cover and surrounding area.
- Remove cover, fill fluid reservoir and install cover.
- Attach one end of a clear plastic hose to rear hydraulic modulator bleeder valve, then submerge other end of hos...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo BRAKE SERVICE PROCEDURES
FUEL FILTER REPLACEMENT PROCEDURES FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
General Motors Corp./Saturn Passenger Cars -> Fuel Filter Replacement -> Except Aveo, Chevette 1.8L Diesel, Corvette, GTO, LaCrosse, Malibu (2004-06) & Malibu Maxx, Vibe, XLR, 2004-05 Corvette & 1998-2002 Metro & Prizm
Vehicle: 2002 Chevrolet Monte Carlo LS 3.4 V6 GAS
Do not smoke or allow an open flame of any type when working on or near any fuel system related components. The highly flammable vapor mixtures may ignite, resulting in serious personal injury.
Prior to disconnecting fuel lines, the fuel system pressure must be relieved to prevent accidental spray of fuel.
After the battery has been disconnected and reconnected, some abnormal driveability symptoms may occur. The vehicle may need to be driven while the v...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo FUEL FILTER REPLACEMENT PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
CV AXLE SHAFT, Replace
Vehicle: 2002 Chevrolet Monte Carlo SS 3.8 V6 GAS
- Raise and suitably support vehicle.
- Remove wheel and tire.
- Remove stabilizer shaft link.
- Remove front wheel drive shaft nut. Insert a drift or a flat-bladed tool into caliper and rotor to prevent rotor from turning.
- Disconnect outer tie rod assembly from steering knuckle.
- Separate ball joint from steering knuckle. Do not attempt to move vehicle with drive axle(s) removed from wheel bearing. Wheel(s) could fall off, dropping vehicle to ground and causing personal injury or damage to vehicle.
- Separate front wheel drive axle from front wheel drive shaft bearing using a suitable pu...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
Description
Vehicle: 2002 Chevrolet Monte Carlo SS 3.8 V6 GAS
The TPMS (Tire Pressure Monitor System) alerts the driver when a large change in the pressure of one tire exists. The system detects a tire pressure condition while the vehicle is in motion, once a tire pressure condition is detected, the system alerts the driver whenever the ignition is turned On.
The software used to calculate the relative tire pressure differences is contained in the EBCM. This software requires approximately 30 minutes of straight line driving in each of three speed ranges to complete the calibration cycle in order to have full capability for detecting the tire p...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
Alternator, Replace
Vehicle: 2002 Chevrolet Monte Carlo LS 3.4 V6 GAS
- Disconnect battery ground cable.
- Remove engine compartment cross vehicle brace.
- Remove serpentine belt.
- Remove coolant recovery reservoir mounting bolts, then position reserv...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo STARTER & ALTERNATOR REPLACEMENT PROCEDURES
CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
Cabin Air Filter Service -> General Motors Corp./Saturn -> 1997-2005 Century, Regal, 1998-2002 Intrigue & 2000-05 Impala & Monte Carlo
Vehicle: 2002 Chevrolet Monte Carlo SS 3.8 V6 GAS
Under normal operating conditions the cabin air filter should be replaced every 15,000 miles. In dusty areas change the cabin air filter more often.
- Place the windshield wipers in the up position by turning the ignition switch Off when the wipers reach the desired position.
- Open the hood.
- Lift the righthand side of the rear hood seal from the flange in the area of the rig...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo CABIN AIR FILTER LOCATIONS & REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
General Motors Corp./Saturn Cars -> Change Oil, Change Oil Now Or Change Oil Soon Lamp & Messages -> 2001-05 Monte Carlo -> Using Accelerator Pedal -> Using Radio
Vehicle: 2002 Chevrolet Monte Carlo LS 3.4 V6 GAS
Using Accelerator Pedal
The Engine Oil Life monitor indicates when an oil and filter change are needed, usually from 3000-10,000 miles since the last change. The CHANGE OIL SOON indicator may light even before 3000 miles if the vehicle has been operated under severe service.
The monitor will not detect dust in the oil. If operating in dusty conditions be sure to change the oil and filter every 3000 miles or sooner if the CHANGE OIL SOON lamp lights.
To reset the Engine Oil Life monitor proceed as follows:
- Turn ignition on, but do not start engine.
- Fully depress and release accele...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
Radiator, Replace
Vehicle: 2002 Chevrolet Monte Carlo SS 3.8 V6 GAS
- Drain engine coolant into suitable container.
- Remove upper radiator seal.
- Remove upper radiator support bar.
- Disconnect and plug coolant overflow hose from radiator.
- Disconnect upper and lower radiator hoses from radiator and position out of way.
- Remove bolt from transmission oil cooler pipe clip at lower radiator tie bar.
- Remove cooling fans.
- Disconnect transmission fluid cooler lines from radiator using coupling tool No. J41623-B, or equivalent. Position lines aside.
- Disconnect overflow hose from radiator.
- The bolt retaining the condenser...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2002 Chevrolet Monte Carlo SS 3.8 V6 GAS
- Rotate tensioner counterclockwise to remove the dri...
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
Component location diagrams for most 2002 Chevrolet Monte Carlo cars and light trucks sold in the U.S. from 1990+.
 Steering Wheel Controls Diagram for 2002 Chevrolet Monte Carlo LS 3.4 V6 GASComponents on diagram: |
 Rear of Left Rear Wheelhouse Diagram for 2002 Chevrolet Monte Carlo LS 3.4 V6 GASComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
OEM drawn wiring diagrams for most 2002 Chevrolet Monte Carlo cars and light trucks sold in the U.S.
 2002 Chevrolet Monte Carlo SS 3.8 V6 GAS Wiring DiagramComponents on diagram: |
 2002 Chevrolet Monte Carlo LS 3.4 V6 GAS Wiring DiagramComponents on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
OEM TSB listings for most 2002 Chevrolet Monte Carlo cars and light trucks sold in the U.S. from 1985+.
|
Document: Revised General Motors New Vehicle Tire Warranty Program Vehicle: 2002 Chevrolet Monte Carlo LS 3.4 V6 GAS Auto Systems: |
|
Document: New Website for AFIT, TPM, and VDR Updates Vehicle: 2002 Chevrolet Monte Carlo LS 3.4 V6 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2002 Chevrolet Monte Carlo AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2002 Chevrolet Monte Carlo cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2002 Chevrolet Monte Carlo cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2002 Chevrolet Monte Carlo cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2002 Chevrolet Monte Carlo cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2002 Chevrolet Monte Carlo SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
| More parts |
